Install grille, Connect wiring service parts, Attach grille to housing – Broan QTXE150 User Manual
Page 4: Push grille against ceiling. 5. finish ceiling, Connect electrical wiring

Page 4
MODELS QTXE050 • QTXE080 • QTXE110 • QTXE150
Key No.
Part No.
Description
1
97016466
Housing
2
97016450
Duct Connector-6"
3
98010102
Wiring Plate
4
99170245
Screw, #8-18 X .375 (2 req’d)
5
97016932
Wire Panel/Harness Assembly
6
99020284
Blower Wheel
7
99080560
Motor (QTXE050)
99080562
Motor (QTXE080)
99080580
Motor (QTXE110)
99080565
Motor (QTXE150)
8
99100491
Isolator (4 req’d)
9
97016468
Motor Plate
10
99250959
Washer #8 (4 req’d)
11
99260558
Nut, Hex Lock #8-32 (4 req’d)
*
97016587
Blower Assembly (QTXE050)
*
97016588
Blower Assembly (QTXE080)
*
97016738
Blower Assembly (QTXE110)
*
97016591
Blower Assembly (QTXE150)
(includes key nos. 6 thru 14)
12
99500397
Insulation (QTXE150 only)
13
99420648
Threaded Stud
(QTXE150 only (4 req’d)
14
99260570
Plastic Nut (QTXE150 only) (4 req’d)
15
99140199
Grille Spring (2 req’d)
16
97016459
Grille Assembly (includes key no. 15)
17
99111293
Spacer (2 supplied)
18
QTHB1
Hanger Bar Kit
99043847A
TAB
Order service parts by “Part No.” - not by “Key No.”
* Not shown assembled.
SERVICE NOTE To remove Blower Assembly: Unplug motor (7). Remove
screw (4) from motor plate (9) flange. Find the single TAB on the motor plate (located
next to the receptacle). Push up near motor plate tab while pushing out on side of housing.
Or insert a straight-blade screwdriver into slot in housing (next to tab) and twist screwdriver.
Replacement parts can
be ordered on our
website. Please visit us
at www.broan.com
INSTALL GRILLE
6. Attach grille
to housing.
Squeeze grille
springs and insert
them into slots on
each side of
housing.
7. Push grille
against
ceiling.
5. Finish ceiling.
Install ceiling material. Cut out around housing.
4. Connect electrical wiring.
Run 120 VAC house wiring to installation location. Use
proper UL approved connector to secure house wiring to
wiring plate. Connect wires as shown in wiring diagrams.
CONNECT WIRING
SERVICE PARTS