Multiquip MQD3H - Manual (Page 8)

PAGE 8 — MQD2H/3H DIAPHRAGM PUMPS — OPERATION AND PARTS MANUAL — REV. #7 (05/24/13)
SAFETY INFORMATION
PUMP SAFETY
DANGER
„ NEVER operate the equipment in an explosive
atmosphere or near combustible materials. An
explosion or fire could result causing severe
bodily harm or even death.
WARNING
„ Accidental starting can cause severe injury
or death. ALWAYS place the ON/OFF
switch in the OFF position.
„ DO NOT place hands or fingers inside
pump when pump is running.
„ NEVER disconnect any emergency or
safety devices. These devices are intended for operator
safety. Disconnection of these devices can cause severe
injury, bodily harm or even death. Disconnection of any
of these devices will void all warranties.
CAUTION
„ DO NOT restrict the flow of the discharge hose as it may
cause overheating.
„ Be careful of discharge whipping under pressure.
NOTICE
„ NEVER operate pump on its side.
„ DO NOT allow up to freeze in water.
„ NEVER leave an open pump chamber unattended.
„ ALWAYS keep the machine in proper running condition.
„ DO NOT attempt to thaw-out a frozen pump by using
a torch or other source of flame. Application of heat in
this manner may heat the oil in the seal cavity above the
critical point, causing pump damage.
„ DO NOT pump water greater than 104º F.
„ DO NOT pump liquids containing acid or alkali.
„ ALWAYS check strainer before pumping. Make sure
strainer is not clogged. Remove any large objects, dirt
or debris from the strainer to prevent clogging.
„ ALWAYS use a large basket strainer when pumping
water that contains large debris.
„ ALWAYS flush pump (clean) after use when pumping
water concentrated with heavy debris. It is very important
to always flush the pump before turning it off to prevent
clogging.
„ Fix damage to machine and replace any broken parts
immediately.
„ ALWAYS store equipment properly when it is not being
used. Equipment should be stored in a clean, dry location
out of the reach of children and unauthorized personnel.
„ NEVER lubricate components or attempt service on a
running machine.
„ ALWAYS allow the machine a proper amount of time to
cool before servicing.
„ Keep machine in proper running condition.
LIFTING SAFETY
CAUTION
„ When raising or lowering of the pump is required, always
attach an adequate rope or lifting device to the correct
lifting point (handle) on the pump.
NOTICE
„ DO NOT lift machine to unnecessary heights.
„ NEVER lift the equipment while the engine is running.
TRANSPORTING SAFETY
NOTICE
„ ALWAYS shutdown pump before transporting.
„ ALWAYS tie down equipment during transport by
securing the equipment with rope.
ENVIRONMENTAL SAFETY
NOTICE
„ Dispose of hazardous waste properly.
Examples of potentially hazardous waste
are used motor oil, fuel and fuel filters.
„ DO NOT use food or plastic containers to dispose of
hazardous waste.
„ DO NOT pour waste, oil or fuel directly onto the ground,
down a drain or into any water source.