Bryan Boilers CLM-120-WT-FDG-844-AV-CM-IN - Manual (Page 4)

Bryan Water-Pak TM Indirect Water Heater Systems
Specifications subject to change without notice.
Contact factory to consult on other boiler options.
Form No. 2300 ©2004 Bryan Steam LLC Printed in USA
54-5368
Indirect Heater Specifications
Heater Model
Output
Series Number
BTU/HR 80°-140° 60°-140° 40°-140° 40°-160°
DR SERIES DR/F-350-WT 280,000 559 420 336 —
(Forced Draft) DR/F-450-WT 360,000 720 540 432 —
F SERIES DR/F-650-WT 520,000 1,039 780 624 —
(Atmospheric) DR/F-850-WT 680,000 1,359 1,020 816 —
CLM SERIES CLM-120-WT 960,000 1,920 1,440 1,152 960
(Forced Draft) CLM-150-WT 1,200,000 2,400 1,800 1,440 1,200
&
CLM-180-WT 1,440,000 2,880 2,160 1,728 1,440
(Atmospheric)
CLM-210-WT 1,680,000 3,660 2,520 2,016 1,680
CLM-240-WT 1,920,000 3,840 2,880 2,304 1,920
CLM-270-WT 2,160,000 4,320 3,240 2,592 2,160
CLM-300-WT 2,400,000 4,800 3,600 2,880 2,400
K SERIES K-350-WT 2,800,000 5,600 4,200 3,360 2,800
(Atmospheric) K-400-WT 3,200,000 6,400 4,800 3,840 3,200
K-450-WT 3,600,000 7,200 5,400 4,320 3,600
K-500-WT † 4,000,000 8,000 6,000 4,800 4,000
K-550-WT † 4,400,000 8,800 6,600 5,280 4,400
K-600-WT † 4,800,000 9,600 7,200 5,760 4,800
K-650-WT † 5,200,000 10,400 7,800 6,240 5,200
AB SERIES AB-90-WT 720,000 1,440 1,080 864 720
(Forced Draft) AB-120-WT 960,000 1,920 1,440 1,152 960
AB-150-WT 1,200,000 2,400 1,800 1,440 1,200
AB-200-WT 1,680,000 3,360 2,520 2,016 1,680
AB-250-WT 2,000,000 4,000 3,000 2,400 1,999
AB-300-WT 2,400,000 4,800 3,600 2,880 2,400
RV SERIES RV-350-WT 2,800,000 5,600 4,200 3,360 2,800
(Forced Draft) RV-400-WT 3,200,000 6,400 4,800 3,840 3,200
RV-450-WT 3,600,000 7,200 5,400 4,320 3,600
RV-500-WT † 4,000,000 8,000 6,000 4,800 4,000
RV-550-WT † 4,400,000 8,800 6,600 4,280 4,400
RV-600-WT † 4,800,000 9,600 7,200 5,760 4,800
RV-700-WT † 5,600,000 11,200 8,400 6,720 5,600
RV-800-WT † 6,400,000 12,800 9,600 7,680 6,400
Bryan Steam LLC — Leaders Since 1916
783 N. Chili Ave., Peru, Indiana 46970 U.S.A.
Phone:765-473-6651 • Internet: www.bryanboilers.com
Fax: 765-473-3074 • E-mail: [email protected]
Water-Pak Selection
Water-Pak units are built to furnish a very wide selection of
recovery rates, storage capacities and configurations. Both
horizontal and vertical tanks are available to best fit into the
space allocation. In addition to the combinations of "settings"
shown below, other combinations, arrangements and sizes
are possible. Fuel selection includes gas (atmospheric or
forced draft), oil, gas-oil or electric (consult factory).
1. Select Heater Model based on "Heater Specifications" table
below.
2. Select storage capacity from "Storage Tank Specifications"
tables, horizontal or vertical tank depending on space
considerations.
3. Choose appropriate "Setting" from "Heater, Tank Setting"
diagrams on previous page.
Selection Procedure Example
A requirement of 800 gph at 100° rise. Storage capacity 1000
gallons. Fuel, gas. Tank lining, cement.
1. From "Heater Specifications" table, select Model No. CLM-
120-WT Gas, rated at 1,152 gph, 40° to 140° rise.
2. From the "Storage Tank Specifications" tables, suppose
you select the 1045 gallon horizontal tank.
3. Then the setting shown in diagram "AH" (horizontal tank)
would be appropriate.
Specify: Specify: Specify: Specify: Specify:
Water-Pak System CLM-120-WT - G - 1045 - AH - CM - IN
Storage Tank Specifications
Tank Tank Approximate
Capacity Dia × Length Weight
gallons in (cm) lbs (Kg)
Horizontal Tanks
H-387 36Ч96 (91.4Ч243.8) 2,000 (907)
H-520 42Ч96 (106.7Ч243.8) 2,200 (998)
H-802 42Ч144 (106.7Ч365.8) 3,000 (1,361)
H-1045 48Ч144 (121.9Ч365.8) 3,800 (1,724)
H-1546 54Ч168 (137.2Ч426.7) 5,600 (2,540)
H-2188 60Ч192 (152.4Ч487.7) 6,900 (3,130)
H-2699 72Ч168 (182.9Ч426.7) 8,100 (3,674)
H-3533 72Ч216 (182.9Ч548.6) 10,100 (4,581)
Vertical Tanks
V-335 36Ч84 (91.40Ч213.4) 1,700 (771)
V-520 42Ч96 (106.7Ч243.8) 2,200 (998)
V-665 48Ч96 (121.9Ч243.8) 2,700 (1,225)
V-844 54Ч96 (137.2Ч243.8) 3,100 (1,406)
V-1030 60Ч96 (152.4Ч243.8) 4,000 (1,814)
V-1447 72Ч96 (182.9Ч243.8) 5,300 (2,404)
V-1922 84Ч96 (213.4Ч243.8) 7,000 (3,175)
Fuel Fuel Fuel Fuel Fuel
G—gas
O—oil
GO—gas-oil Storage Storage Storage Storage Storage
Section
Section Section Section Section
Size
Size Size Size Size
(gals.)
Tank Tank Tank Tank Tank
Insulated
Insulated Insulated Insulated Insulated
PVC
PVC PVC PVC PVC
Jacket
Jacket Jacket Jacket Jacket
Indirect Indirect Indirect Indirect Indirect
Heater
Heater Heater Heater Heater
Model
Model Model Model Model
Setting Setting Setting Setting Setting Tank Lining Tank Lining Tank Lining Tank Lining Tank Lining
CM—cement
PH—phenolic
Gallons Per Hour*
Heater Capacity
† These units are equipped with two heat exchangers as standard and require a copper header to be field supplied.
* Note 1: Contact factory for ratings at other conditions.
Note 2: Heater is not intended to provide the temperature increases shown above instantly, but will raise the
temperature of the gallons listed to final storage temperature within one hour.
Note 3: Select adequate storage tank capacity to handle peak demand. Keep in mind that, typically, only 75%
of tank capacity is usable storage.