Autoquip XLR AIR - Manual (Page 27)

27
24V.
L3 L1 L2
L1
L2
3/4 HORSEPOWER MOTOR: 230 VOLT 1 PHASE 60 CYCLE
(BY OTHERS)
60 CYCLE 230 VOLT 1 PHASE
O.L.
T2 T3 T1
L2
L1
L1 L2
DN. SOL.
ELECTRICAL SCHEMATIC
IDENTIFICATIONS
RED - DOWN SOLENOID
WHITE - MOTOR BLACK - MOTOR
ELECTRICAL LEAD (PIG TAIL)
CONNECTION No. ON DEVICE. COLOR CODE STANDARD PUSHBUTTON GREEN - EQUIPMENT GROUND
ORANGE - DOWN SOLENOID
(GRN)
(GRN)
230V.
(XF)
LOCATED ON INSIDE OF FRONT COVER. TRANSFORMER PRIMARY CONNECTION DIAGRAMS ARE LOOSE WHEN ORDERED. TO BE INSTALLED AND WIRED
3.
OPTIONAL FOOTSWITCH W/ GUARD (NEMA 1) SHIPPED
2. 1.
PRE-WIRED, AND MOUNTED TO POWER UNIT. MOTOR STARTER, CONTROL TRANSFORMER, OVERLOADS, AND FUSES TO BE MOUNTED IN NEMA 1 ENCLOSURE,
(WHEN USED)
SWITCH
"UP" LIMIT
CONTACTOR
FOOT SWITCH
(BLUE)
(BLACK)
(BLACK) (WHITE)
COIL
TYPICAL PILOT CONTROLS ONLY
2.5 AMP FUSE
SEE NOTE #3
PUSHBUTTON
CONTACTS
MOTOR STARTER
MOTOR STARTER
CONTACT
O.L. RELAY
TRANSFORMER
(GRN.)
(BY OTHERS) FUSED DISCONNECT
(WHITE)
Figure 11 Electric Schematic; 230V/1Ph
GENERAL MAINTENANCE