JLG 600SC_660SJC Operator Manual - Manual (Page 22)

SECTION 2 - PREPARATION AND INSPECTION
2-8 – JLG Lift – 3120897
27. Dual Capacity Limit Switch - Properly secured, no
damage to the switch, arm free to move, and free
from dirt and grease.
28. Left Track Belt - No excessive damage. No cuts or
delamination of the carcass. Proper tension.
29. Idler, Right Front - No visible damage, no evidence
of leakage.
30. Left Tension Mechanism - No visible leakage, no
visible damage.
31. Bottom Rollers, Left Side - No loose or missing
bolts, no evidence of leakage, no visible damage.
32. Battery - Proper electrolyte levels; cables tight, no
visible damage or corrosion.
33. Door and Latches, Left Side - Hood door and
latches in working condition, properly secured, no
loose or missing parts.
34. Engine Air Filter - No loose or missing parts; no vis-
ible damage; element clean.
35. Engine Oil Supply - Full mark on dipstick; filler cap
secure.
36. Muffler and Exhaust System - Properly secured, no
evidence of leakage
37. Hydraulic Pump - No loose or missing parts, no evi-
dence of leakage.
38. Engine Tray Pivot - No loose or missing parts, no
visible damage.
39. Hydraulic Oil Medium Pressure Filter Housing -
Housing secure; no visible damage; no evidence of
leakage.
40. LP Gas Tank - Brackets, hose and fittings secure;
no visible damage, no missing parts. (If Equipped)
41. Flow Valves - No visible damage, no evidence of
leakage, no unsupported wires or hoses, no dam-
aged wires.
42. Horizontal Cutoff Limit Switch - (High Engine/High
Drive Cut-off Switch) properly secured, no damage
to the switch, arm free to move, and free from dirt
and grease.
43. Frame - No visible damage, no loose or missing
hardware (top and underside).
44. Hydraulic Swivel - No loose or missing parts, no
evidence of leakage.
45. Main Boom Sections - No visible damage; wear
pads secure. All cylinders - rod end shafts and bar-
rel-end shafts properly secured; evidence of proper
lubrication.
46. Platform Pivot Pin - Properly secured; no evidence
of damage.
Figure 2-4. Daily Walkaround Inspection Points - Sheet 2