JLG 500RTS ANSI Parts Manual - Manual (Page 107)

3120697 400RTS 500RTS 2-57
SECTION 2 GROUND CONTROLS
2000242 Ref. ENGINE COMPONENTS - DEUTZ F3L2011F (S/N 121830 to
Present) A
Ref. Note: Parts Below Not Shown on Figure 2-11
251 7027248 1 Dipstick
252 7024579 1 Gear, Ring
253 7020465 1 Cap, Filler
254 7020495 1 Pump, Oil
7020468 1 Seal Between Oil Pump & Engine Block
255 7016331 1 Filter, Oil
256 7027236 1 Sender, Oil Temperature
257 Use 7027246 3 Pump, Injector (was p/n 7027242)
Use 7027608 3 Pump, Injector (was p/n 7027611)
Use 7027609 3 Pump, Injector (was p/n 7027612)
Use 7027610 3 Pump, Injector (was p/n 7027613)
7020447 1 Gasket, Compensation
258 7020023 1 Filter, Fuel
259 Use 70000916 1 Pump Fuel Supply (was p/n 7027238)
7020411 1 O-Seal Between Fuel Pump & Engine Block
260 7027245 1 Filter, Fuel In Line
261 Use 70001871 3 Gasket, Intake Manifold (was p/n 7020449)
262 7027239 1 Solenoid, Start Assist
263 7020414 1 V-Belt
264 7020471 3 Gasket, Exhaust Manifold to Exhaust Pipe
265 7020479 1 Starter
7026608 1 Relay
266 7020417 1 Alternator
7027252 Regulator, Voltage
267 Use 7016330 1 Sensor, Oil Pressure (was p/n 7020443)
268 7027241 1 Transmitter, Temperature
269 7027251 1 Device, Shutdown
7027249 1 O-Ring
7027250 1 Spring, Tension
270 7020449 3 Gasket, Intake
271 7020471 3 Gasket, Exhaust
272 Use 70003475 1 Thermostat (was p/n 7020459)
7020460 1 Spring, Compression
Ref. PUMP COUPLING INSTALLATIONS:
0250597 Ref. PRIOR TO S/N 30660 —
0256848 Ref. S/N 30660 TO PRESENT 2
301 1 Coupling (Hayes) Options:
1660184 Prior to S/N 30660
1660234 S/N 30660 to Present
Ref. Note: Coupling Spine must be greased with lithium soap
based grease prior to installation.
302 0080163 1 Adapter, Pump Mounting
303 0700810 6 Bolt, Metric 8mm x 20mm
304 4831900 6 Lockwasher 8mm
FIGURE 2-11. ENGINE INSTALLATION - DEUTZ F3L1011 (CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.