JLG 3246E2 Parts Manual - Manual (Page 57)

3120856 2-23
SECTION 2 GROUND COMPONENTS
S
E
C
T
I
O
N
2
G
R
O
U
N
D
C
O
M
P
O
N
E
N
T
S
.
FIGURE 2-6. ELECTRICAL COMPONENT INSTALLATIONS (LEFT SIDE OF MACHINES WITH
PROPORTIONAL CONTROLS)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.
ELECTRICAL COMPONENTS INSTALLATIONS (LEFT SIDE
OF MACHINES WITH PROPORTIONAL CONTROLS) Ref.
0259409 3246E2 (CE Spec) Ref. D
0259407 3246E2 (CE Spec with Optional Charger Interlock) Ref. D
0259407 3246E2 (Australian Spec) Ref. D
1 0100011 Loctite #242 A/R
2 0100048 Grease, Dialectic (Not Shown) A/R
3 0100051 Grease, Terminal A/R
4 0100076 Compound, Silicone Release A/R
5 0641404 Bolt 1/4”-20NC x 1/4” 6
6 0641405 Bolt 1/4”-20NC x 5/8” 2
7 0641408 Bolt 1/4”-20NC x 1” 4
8 0840025 Boot, Cable 8
9 Bracket, Ground Control Options: 1
Use 0902615 Prior to S/N 73083 (Was p/n 0902584)
0902615 S/N 73083 to Present
10 1060666 Cable, Battery (Contactor to Motor) 1
11 1060680 Cable, Electrical - 18/2 (Not Shown) 2FT/.6m
12 1060763 Cable, Battery (Contactor to Controller B+) 1
13 1060764 Cable, Battery (Controller A to Motor) 1
14 1600289 Controller, Smart System (Apply Item #4 on entire back
surface of unit when replacing) 1
15 2600231 Hinge 1
16 2940119 Latch, Panel 1
17 Locknut Options: 1
3311005 Locknut #10-24NC
3300408 Locknut, Nylon Insert
18 3311401 Nut 1/4”-20NC 5
19 3311402 Nut, Jam 1/4”-20NC 6
20 3311405 Locknut 1/4”-20NC 6
21 3571652 Plate, Controller Mounting 1
22 3740069 Relay, Power 1
23 3740131 Contactor, Main 1
24 3910804 Screw, Round Head #8-24NC x 1/2” 3
25 3911008 Screw, Round Head #10-24NC x 1” 1
26 Shim Options: A/R
4070987 Shim (.015) (S/N 69428 to S/N 85982 Only) 5
4071006 Shim (0.090) (S/N 85982 to Present Only) 1
27 4300133 Stud, Brass 1/4”-20NC x 1 1/2” 3
28 4360112 Breaker, Circuit - 5 Amp 1
29 4360328 Switch, Toggle 1
30 4360470 Switch, Key 1
30A 2860030 Key, Replacement 1
31 4360475 Switch, Emergency Stop 1
7020175 Head, Mushroom 1
7020176 Block, Contact 1