JLG 500RTS Parts Manual User Manual
Page 66
2-18
SECTION 2 GROUND CONTROLS
145
1060360
1
Cable, Battery (Battery Neg to Ground)
146
0630370
2
Rod, Tie-Down
147
0400002
1
Tie-Down, Battery
2910479
2
Clips, Tie Down
148
3620027
1
Radiator
149
Not Used
150
1320020
1
U-Clamp 1 1/2"
151
1320026
1
U-Clamp 1 3/4"
0252808
Ref.
PUMP COUPLING INSTALLATION (STANDARD PARTS)
—
201
1660207
1
Coupling, Pump
202
0080163
1
Adapter, Pump Mounting
203
0700808
6
Bolt, Metric 8mm 1.25 x 16mm
204
4831900
6
Lockwasher, Metric 8mm
205
0641610
8
Bolt 3/8"-16NC x 1 1/4"
206
4761600
8
Lockwasher 3/8"
— — — — — — — — — —
3020021
A/R
Grease, Coupling
Note: Coupling Spine must be greased with lithium soap
based grease prior to installation.
0250815
Ref.
ENGINE HEATER INSTALLATION (OPTIONAL - NOT SHOWN)
A
2580026
1
Heater, Engine Coolant (Located at Rear of Cylinder Head)
0701020
2
Bolt, Metric 10mm x 6mm
4564328
2
Spacer, Tube
Ref.
SPARE COMPONENTS
301
7000892
1
Carburetor (Standard Gas)
1140009
1
Carburetor (LP Gas)
— — — — — — — — — —
Use 7019933
1
Carburetor Rebuild Kit (p/n was 7000878)
7023471
1
Assembly, Float (Not Shown)
70000163
1
Needle-Spring Load Fuel Valve
7012577
1
Fitting, Vacuum Line
7012578
1
Vacuum Line Assembly
7000884
1
Fuel Shut-Off
7024321
1
Gasket, Carburetor (Top)
7027607
1
Gasket, Carburetor (Bottom)
302
7012564
1
Wiring Harness
7014682
1
Tune-Up Kit (Includes Oil and Fuel Filters, Spark Plugs and
Wire Set) (“Push On” Spark Plug Wires)
7019998
1
Coil Pack (“Push On” Spark Plug Wires)
7023669
1
Plug Wire Set (“Push On” Spark Plug Wires)
7023668
1
Tune-Up Kit (Includes Oil and Fuel Filters, Spark Plugs and
Wire Set) (“Clip On” Spark Plug Wires)
7019939
1
Filter, Fuel (Not Shown)
7019949
1
Filter, Oil (Not Shown)
FIGURE 2-4. ENGINE INSTALLATION - FORD VSG-411 (CONTINUED)
ITEM #
PART NUMBER
QTY.
DESCRIPTION
REV.