JLG 500RTS Parts Manual User Manual
Page 102
2-54
SECTION 2 GROUND CONTROLS
90
1703476
1
Decal - Battery Connect and Disconnect (CE Spec Only)
91
4740308
2
Washer, Thick (S/N 34060 to Present)
92
4832000
2
Lockwasher (S/N 34060 to Present)
93
0701016
2
Bolt 10mm x 40mm (S/N 34060 to Present)
94
0840046
1
Boot, Battery Pos. (S/N 83238 to Present)
95
0840047
1
Boot, Battery Neg. (S/N 83238 to Present)
96
2220273
2
Fitting, Reducer (S/N 101987 to Present)
97
1320095
1
Clamp, Support (Not Shown) (S/N 103576 to Present)
(Australian Spec Only)
98
4923062
1
Harness, Start Assist Solenoid (Not Shown) (S/N 121830 to
Present)
— — — — — — — — — —
0100043
A/R
Sealant, Pipe (Prior to S/N 103576)
2000107
Ref.
ENGINE COMPONENTS - DEUTZ F3L1011 (Prior to July 1995)
A
Ref.
Note: Parts Below Not Shown on Figure 2-11
101
7020455
1
Muffler (was p/n 7000694)
102
7014684
1
Filter and Gasket Kit (Includes Fuel Line Washer,
Oil Plug Washer, Oil Filter, Fuel Filter, Injector Tip
Gasket and Valve Cover Gasket)
103 to 105
Not Used
106
7027210
1
Sender, Oil Temperature
107 to 108
Not Used
109
7012626
1
Starter
110
7020457
1
Alternator
111
Not Used
112
70003622
3
Injector
7020424
3
Gasket, Injector Tip
113
7012698
1
Pump, Fuel Supply
7016309
1
Washer, Copper
114
7016308
1
Ring, Air Intake (Plastic)
115
7019607
1
Shutdown, Throttle
116
7020471
3
Gasket, Exhaust
117
7020477
1
Ring Gear Only
118
7027250
1
Spring, Tension
2000138
Ref.
ENGINE COMPONENTS - DEUTZ F3L1011F (July 1995 to
S/N 121830)
A
Ref.
Note: Parts Below Not Shown on Figure 2-11
201
Use
7020455
1
Muffler (was p/n 7000694)
202
Not Used
203
7016328
1
Filter, Fuel
204
7016331
1
Filter, Oil
205
Use
7019607
1
Device, Shutdown (was p/n 7016359)
206
7020168
1
Sender, Oil Temperature
207
7020220
1
Harness
208
7020414
1
V-Belt
FIGURE 2-11. ENGINE INSTALLATION - DEUTZ F3L1011 (CONTINUED)
ITEM #
PART NUMBER
QTY.
DESCRIPTION
REV.