Snorkel TB66J - Manual (Page 4)

Table of Contents
TB66J – 0083740
Chapter 7 – Prestart Inspection
Operator’s Manual ..................................................29
Engine ....................................................................29
Oil Level ..............................................................29
Coolant ................................................................29
Radiator ...............................................................30
Fuel Tank .............................................................30
Fuel Line .............................................................31
Air Filter ...............................................................31
Charging System ................................................31
Cold Weather Start Kit ........................................31
Electrical System ....................................................32
Battery Fluid Level ..............................................32
Battery Terminals .................................................32
Cables and Wiring Harness ....................................32
Hydraulic System....................................................32
Fluid Level ...........................................................32
Fluid Filter ...........................................................33
Hoses, Tubes, and Fittings ..................................33
Tires and Wheels ....................................................33
Lower Control Station .............................................34
Operating Controls ..............................................34
Emergency Stop ..................................................34
Emergency Power ...............................................34
Emergency Lowering ..............................................34
Level Sensor...........................................................35
Flashing Light .........................................................35
Sandblast Protection Kit .........................................36
Structures ...............................................................36
Weldments ..........................................................36
Slide Pads ...........................................................36
Wire Ropes .........................................................36
Fasteners ............................................................37
Upper Control Station .............................................37
Guardrail System ................................................37
Lanyard Anchors .................................................38
Operating Controls ..............................................38
Emergency Stop ..................................................38
Emergency Power ...............................................38
Horn ....................................................................39
Electrical Power Outlet ........................................39
All Motion Alarm......................................................39
Air Line to Platform .................................................39
Driving and Platform Work Lights ...........................39
Tow Kit ....................................................................40
Platform Glazier Package .......................................40
Platform Control Cover ...........................................40
Placards and Decals...............................................40
Prestart Inspection Checklist ..................................47
Chapter 8 – Operation
Cold Weather Start Up ...........................................49
Engine Cold Weather Start Kit ................................49
Cummins, Kubota and Ford – Block Heater ........49
Cummins – Ether Injection ..................................49
Deutz – Manifold Preheater ................................50
GM – Radiator Hose In-Line ...............................50
Hydraulic System Cold Weather Warm-Up ............50
Hydraulic System Warm-up Switch .....................50
Manually Warming The Hydraulic System ..........50
Preparing for Operation ..........................................50
Lower Controls .......................................................50
Upper Controls .......................................................51
Boom Operation ..................................................52
Driving and Steering ............................................52
Drive Speeds .......................................................53
Motion Warning Alarm .........................................53
Four Wheel Drive....................................................53
Gradeability ............................................................53
Percent vs. Degree of Slope ...............................54
Driving on a Slope ...............................................54
Calculating Percent Grade ..................................54
Machine Gradeability ..........................................55
All Motion Alarm......................................................55
Four Wheel Drive....................................................55
Electrical Power Outlet ...........................................55
AC Generator .........................................................55
Dual Fuel ................................................................56
Air Line ...................................................................56
Driving Lights ..........................................................56
Platform Work Lights ..............................................56
Platform Glazier Package .......................................57
Platform Capacity ................................................57
Bump Guard System ..............................................57
Chapter 9 – Stowing and Transporting
Stowing ...................................................................59
Transporting ...........................................................59
Driving .................................................................59
Winching .............................................................60
Hoisting ...............................................................60
Securing for Transport .........................................61
Chapter 10 – Emergency Operation
Emergency Power System .....................................63
Lower Controls ....................................................63
Upper Controls ....................................................63
Emergency Lowering ..............................................64
Towing ....................................................................65
Chapter 11 – Troubleshooting
Troubleshooting Chart ............................................67
Appendix A – Glossary
Limited Warranty