Graymills DDP 1' Pump OMI - Manual (Page 3)

3
TOXIC FLUID HAZARD
Hazardous fluid or toxic fumes can cause serious injury or death if splashed in the eyes or on the skin,
inhaled, or swallowed.
D Know the specific hazards of the fluid you are using.
D Store hazardous fluid in an approved container. Dispose of hazardous fluid according to all local, state
and national guidelines.
D Keep containers closed when not in use.
D Always wear protective eyewear, gloves, clothing and respirator as recommended by the fluid and solvent
manufacturer.
D Pipe and dispose of the exhaust air safely, away from people, animals, sources of ignition, and food
handling areas. If the diaphragm fails, the fluid is exhausted along with the air. See Air Exhaust Ventila-
tion on page 10.
D To pump acids, always use a polypropylene pump. Take precautions to avoid acid or acid fumes from
contacting the pump housing exterior.
D Use static wire hoses when pumping flammables.
FIRE AND EXPLOSION HAZARD
Improper grounding, poor ventilation, open flames or sparks can cause a hazardous condition and result in a
fire or explosion and serious injury.
D Ground the equipment. Refer to Grounding on page 5.
D Never use a polypropylene pump with non-conductive flammable fluids as specified by your local fire
protection code. Refer to Grounding on page 5 for additional information. Consult your fluid supplier
to determine the conductivity or resistivity of your fluid.
D If there is any static sparking or you feel an electric shock while using this equipment, stop pumping
immediately. Do not use the equipment until you identify and correct the problem.
D Provide fresh air ventilation to avoid the buildup of flammable fumes from solvents or the fluid being
pumped.
D Pipe and dispose of the exhaust air safely, away from all sources of ignition. If the diaphragm fails, the
fluid is exhausted along with the air. See Air Exhaust Ventilation on page 10.
D Keep the work area free of debris, including solvent, rags, and gasoline.
D Electrically disconnect all equipment in the work area.
D Extinguish all open flames or pilot lights in the work area.
D Do not smoke in the work area.
D Do not turn on or off any light switch in the work area while operating or if fumes are present.
D Do not operate a gasoline engine in the work area.
WARNING