A.J. Antunes & Co MS-250 9100439 - Manual (Page 16)

16 P/N 1010984 Rev. D 03/12
replaceMenT parTS (continued)
1 0010159 Filter Assy., Water 1
Tank (MS-150)
2 7000652 Relay 1
3 0010584 Inlet Hose Assy. 1
w/ Strainer (MS-250)
4 7000137 Pump/Tube Assy., 1
24VAC (MS-150)
5 4040145 Solenoid Valve 24VAC 1
(MS-250)
6 7000237 Top Cover Assy. 1
(Incl. #41 & #42)
7 0011314 Steam Vent Assy. 1
8 0021131 Floor/Chassis Weld. 1
9 0012547 Access Cover Weld. 1
(MS-150)
10 7000246 Generator, 230V 1
7000245 Generator, 208V 1
7000300 Generator, 120V 1
11 0300129 Stud, Cover Hold Down 1
12 040P138* Locknut, 1/2"
1
13 040K251 Strain Relief 1
(Includes #12)
14 05P2199* Spacer 2
15 0503988 Spatula 1
(for Mfg: #9100427,
432, 433, & 439)
16 0505727 Spatula (for Mfg. 1
#9100427 & 434)
17 0503433 Cover, Generator 1
18 0503434 Cover, End Housing 1
19 0503435 Retainer, Thermocouple 1
20 0503431 Diffuser, Steam
1
21 0021314 Liner, Cavity 1
22 0503441 Access Cover (MS-250) 1
23 0503472 Bracket, Hi-Limit
1
Support
24 0700452 Power Cord, NEMA
6-20P
0700453 Power Cord, CEE 7/7 1
0700463 Power Cord, NEMA 1
5-15P
25 100P967 Label, Marking 1
26 1001247 Label Control Panel 1
(for Mfg. #9100427
& 434)
27 1001036 Label, Control Panel 1
(for Mfg. #9100432,
433, 424, & 439)
28 2000203 Tube, Restrictor, 1/4" 1
29 2000207 Tube, Inlet, 1/4" x
1
2-1/2" Long (MS-250)
30 2040103 Connector, Male, 1/4" 1
x 1/8 NPT (MS-250)
31 2040106 Adapter, Tube/Hose 1
(MS-150)
32 2040145 Elbow, Female, 1/8" 1
x 1/4"
33 2040146 Tee, Female, 1/8" 1
x 1/4"
34 7000693 Water Fitting Kit, 1
MS-150 (Incl. #28,
31, 32, & 33)
35 7000694 Water Fitting Kit, 1
MS-250 (Incl. #28, 29,
30, 32, & 33)
36 2100119 Handle, Spatula 1
37 4050180 Heat Sink 1
38 210K108 Foot, Rubber (4-Pack) 1
39 7000320 Spatula Kit (Incl. #15, 1
36, 74, 75, & 79)
40 0011123 Solenoid Valve Assy. 1
(Incl. #5 & 47)
41 2100249 Guard, Knob 1
42 2100273 Knob 1
43 211P101 Clamp, Hose, 3/8" 1
(MS-150)
44 211P185 Clamp, Hose 1
(MS-150)
45 0503429 Support, Generator 1
Upper.
46 7000449 Generator Tube, 1
4-1/2" Lg. (MS-250)
7000446 Generator Tube, 2
3-5/8" (MS-150)
47 7000138 Quick Disconnect 1
Female Kit
48 300P102* Nut, Speed, “U”, 2
#8-32
49 304P105* Nut, Hex, KEPS, 1
#4-40, Zinc
50 306P101* Nut, Hex, #6-32 2
51 306P105* Screw, Machine, 2
#6-32 x 1/2"
52 306P123* Screw, Machine, 2
#6-32 x 7/8"
53 306P130* Nut, Hex, KEPS, #6-32 2
54 306P134* Screw, Machine,
3
#6-32 x 3/8"
55 308P103* Screw, Machine, 6
#8-32 x 1/4"
56 7000849 Silicon Tube Kit, Water 1
Pump (MS-150)
57 308P105* Screw, Machine, 4
#8-32 x 1/2"
58 308P120* Screw, Machine, 4
#8-32 x 5/8" (sltrshd)
59 308P124* Screw, Machine, 1
#8-32 x 1/2" (one-way)
60 308P143* Nut, Hex, KEPS, #8-32 2
61 310P136* Screw, Machine,
4
#10-32 x 1-1/4"
(splanhd)
62 310P149* Screw, Machine, 2
#10-32 x 7/8"
63 310P149* Screw, Machine, 2
#10-32 x 7/8" (MS-150)
64 325P170* Nut, Wing, 1/4-20 1
65 7000542 Rocker Switch, 1
Power On/Off 250V
7000541 Rocker Switch, 1
Power On/Off 120V
66a 4010190 Switch, Momentary, 1
Square (for Mfg
#9100424, 432, 433,
& 439)
66b 4010233 Switch, Momentary, 1
Round (for Mfg.
#9100427 & 434)
67 7000319 Transformer, 1
115-230/24V
68 7000135 Thermostat, Hi-Limit 1
69 4050214 Thermocouple, Type-K 1
70 406P107 Cable Tie
3
71 7000136 Terminal Block, 3-Pole 1
72 7000317 Control Board,
1
Temperature/Timer,
24V, 50/60 Hz
73 338P102* Bolt, Handle Mounting 1
74 0503536 Drip Pan
1
75 2100118 Guard, Handle 1
76 See page 17 for Strainer parts
Identification.
77 7000139 Quick Disconnect
1
Insert (MS-250)
78 0011370 2" Leg Kit (Incl. #35) 4
78a 210K134 4" Leg Kit (not shown) 1
78b 210K123 4" Leg Kit (optional) 1
(not shown)
79 0800359 Trivet, Spatula 1
* Only available in quantities of 10.
Item part No. Description Qty. Item part No. Description Qty. Item part No. Description Qty.