Bromine standpipe installation – AquaStar ChemStar On-line Chlorinator User Manual

Page 4

flow to pool

flow from equipment

1 CH1007

Body

2 CH1008 O-ring, #128, viton

3 CH1005 Diverter tee

4 CH1004 3" threaded cap

5 CH1009 O-ring, #343, viton

6 CH1010

Check valve

7 CH1015 ½" MPT PVC plug

8 CH1016 2" x 1½" S x S bushing, qty 2*

9 CH1017 ½" NPT x tube fitting w/nut, qty 2

10 CH1018 ½" x short MPT nipple

11 CH1019 ½" chlorine control valve

12 CH1026 ⅝" OD chlorinator tube

13 CH1027 Tube support spring

14 CH1029 Screen**

15 CH1030

Standpipe adapter

16 CH1031 ⅝" OD 18" tube (optional top feed)

17 CH1036 #8 x ½" lg slotted hex head screw

18 CH1059 Silicone lubricant

*Not used with 2" PVC, for 1½" PVC only.

**Be sure screen has not come loose in shipment.

If loose, snap over four posts in bottom of

chlorinator to replace.

NOTE: To service check valve (6), remove

screw (17), unscrew (counter-clockwise)

chlorinator body (1) from diverter tee (3).

BROMINE STANDPIPE INSTALLATION

Do not install chlorinator into copper plumbing. Pipe damage could occur. Never install chlorinator before heater.

heater damage could occur.

You may substitute bromine tablets or sticks for trichlor in this chlorinator. Do not mix. Calcium hypochlorite is not to be used in any form.

To increase erosion of small bromine tablets, install Bromine Standpipe as follows:

Remove screen from bottom of chamber exposing check valve (6). Insert adapter (15) into check valve opening.

Cut supplied ⅝" black tube (16) to 6" length and push tube into adapter opening.

Filter

Heater

Pump

Feeder

Pool / Spa

Skimmer

Typical installation with heater

Filter

Pump

Pool / Spa

Skimmer

Feeder

Typical installation without heater

technical support: (877) 768-2717

ChemStar is a trademark and/or a registered trademark of AquaStar Pool Products, Inc. and/or its affiliated

companies in the United States and/or other countries. Unless noted, names and brands of others that may

be used in this document are not used to indicate an affiliation or endorsement between the proprietors of

these names and brands and AquaStar Pool Products, Inc. Those names and brands may be the trademarks

or registered trademarks of those parties or others.

0213

MODEL CH100

Bottom Feed

Top Feed

Chamber Capacity - 1" Tablet

Quantity

Weight

3.5 lbs

Chamber Capacity - 3" Tablet

Quantity

Weight

4.8 lbs

Maximum Erosion in 24 Hours

0.67 lbs

1.75 lbs

Treat Pool/Spa Size in Gallons per 24 Hours*

@ 10 ppm

6,700

17,500

@ 5 ppm

13,400

35,000

@ 2½ ppm

26,800

70,000

Dimension

17¾" H x 5" W x 10" D

Service Clearance for Lid Removal

19"

*using 1" Trichlor tabs