State SSED 5 thru SSED 120 - Manual (Page 16)

16
HIGH TEMPERATURE LIMIT CONTROLS (ECO)
7KLV ZDWHU KHDWHU LV HTXLSSHG ZLWK DQ (&2 HQHUJ\ FXW RXW QRQ
DGMXVWDEOH KLJK WHPSHUDWXUH OLPLW FRQWURO $Q (&2 LV D QRUPDOO\
FORVHGVZLWFKWKDWRSHQVDFWLYDWHVRQDULVHLQWHPSHUDWXUH,IWKH
(&2VZLWFKFRQWDFWVRSHQDFWLYDWHGXHWRDEQRUPDOO\KLJKZDWHU
temperatures the control system will lock-out and disable further
KHDWLQJ HOHPHQW RSHUDWLRQ ,W LV LPSRUWDQW WKDW D TXDOL¿HG VHUYLFH
agent be contacted to determine the reason for the ECO activation
before resetting the ECO. Once the reason has been determined
DQGFRUUHFWHGWKH(&2FDQEHUHVHWDVIROORZV
The ECO high temperature limit switch is located inside the immersion
WHPSHUDWXUHSUREHWZRUHGZLUHV7KH(&2VZLWFKFRQWDFWVZLOORSHQ
ZKHQWKHZDWHUWHPSHUDWXUHUHDFKHVDSSUR[LPDWHO\ƒ)ƒ&DQG
FORVHDWDSSUR[LPDWHO\ƒ)ƒ&:KHQWKH(&2VZLWFKFRQWDFWV
RSHQDFWLYDWHWKHHOHFWURQLFFRQWUROV\VWHPORFNVRXWDQGGLVSOD\VD
)DXOWPHVVDJH9ROWDJHWRWKHFRQWDFWRUFRLOVDQGKHDWLQJHOHPHQWV
LVWHUPLQDWHGWRSUHYHQWIXUWKHUKHDWLQJRSHUDWLRQ6KRXOGWKH(&2
DFWLYDWHWKHZDWHUWHPSHUDWXUHPXVWGURSEHORZƒ)ƒ&EHIRUH
the control system can be reset. Once the water temperature has
cooled below this point the power supply to the water heater must be
turned off and on again to reset the control system.
THERMOSTAT CONTROLS
The water heaters covered in this instruction manual are equipped
ZLWKDGMXVWDEOHWKHUPRVWDWFRQWUROVWRFRQWUROZDWHUWHPSHUDWXUH+RW
water temperatures required for automatic dishwasher and laundry
use can cause scald burns resulting in serious personal injury and/
or death. The temperature at which injury occurs varies with the
person’s age and duration of exposure. The slower response time
of children, the elderly or disabled persons increases the hazards to
them. Never allow small children to use a hot water tap or draw their
own bath water. Never leave a child or disabled person unattended in
a bathtub or shower. The water heater should be located in an area
where the general public does not have access to set temperatures.
6HWWLQJ WKH ZDWHU KHDWHU WHPSHUDWXUHV DW ƒI ZLOO UHGXFH WKH
ULVN RI VFDOGV 6RPH 6WDWHV UHTXLUH VHWWLQJV DW VSHFL¿F ORZHU
temperatures.
)LJXUHVKRZVWKHDSSUR[LPDWHWLPHWREXUQUHODWLRQVKLSIRUQRUPDO
adult skin.
TEMPERATURE ADJUSTMENT
The water heaters covered in this instruction manual are equipped
with an electronic control system. The control system senses
temperature from a factory installed immersion temperature probe
± VHH WKH )HDWXUHV DQG &RPSRQHQWV LOOXVWUDWLRQV DW WKH EHJLQQLQJ
RIWKLVPDQXDOIRUORFDWLRQ7KH³2SHUDWLQJ6HW3RLQW´LVDGMXVWHGWR
control water temperature. This is an adjustable user setting in the
FRQWUROV\VWHP¶V³7HPSHUDWXUHV0HQX´7KLVDQGDOOFRQWUROV\VWHP
PHQXVDUHDFFHVVHGWKURXJKWKH8,08VHU,QWHUIDFH0RGXOHVHH
)LJXUHORFDWHGRQWKHIURQWSDQHORIWKHZDWHUKHDWHU
7KH2SHUDWLQJ6HW3RLQWLVDGMXVWDEOHIURPƒ)ƒ&WRƒ)ƒ&
7KHIDFWRU\VHWWLQJLVƒ)ƒ&6HHWKH&RQWURO6\VWHP2SHUDWLRQ
section of this manual for instructions on how to adjust the Operating
6HW3RLQWDQGRWKHUXVHUVHWWLQJV
6HWWKH2SHUDWLQJ6HW3RLQWDWWKHORZHVWVHWWLQJZKLFKSURGXFHVDQ
acceptable hot water supply. This will always give the most energy
HI¿FLHQWRSHUDWLRQ
Water Temperature
ƒ)ƒ&
7LPHIRUVW'HJUHH%XUQ
/HVV6HYHUH%XUQV
7LPHIRU3HUPDQHQW%XUQV
QG UG'HJUHH
0RVW6HYHUH%XUQV
QRUPDOVKRZHUWHPS
SDLQWKUHVKROG
35 minutes 45 minutes
1 minute 5 minutes
5 seconds 25 seconds
2 seconds 5 seconds
1 second 2 seconds
instantaneous 1 second
86*RYHUQPHQW0HPRUDQGXP&36&3HWHU/$UPVWURQJ6HSW
FIGURE 3.
TEMPERATURE REGULATION