PEP Filters SMF2-FG - Manual (Page 12)

SMF2-FG Series Media Filter
Operating & Maintenance Manual
PEP Filters • 322 Rolling Hill Road • Mooresville, NC 28117 • 800-243-4583 • www.pepfilters.com
704-662-3133 (Outside USA) Page 11 of 16 Fax 704-662-3155
rev. 01/02
1. O-ring or gasket for filter tank access port, hand hole and manhole gaskets.
2. O-ring seal or gasket for pump pre-strainer lid (if applicable).
3. Seal kit for pump
4. Transformer fuse (automatic units only).
SAFETY PRECAUTIONS
All electrical, mechanical and rotating machinery constitute a potential hazard, particularly
for those not familiar with its design, construction, and operation. Accordingly, adequate
safeguards (including use of protective enclosures when necessary) should be taken with
this equipment both the safeguard the public (including minors) from injury and to prevent
damage to the equipment, its' associate system and the premises
Equipment operation, maintenance and repair should be undertaken by qualified
personnel. All such personnel should be thoroughly familiar with the equipment, the
associated system and controls, and the procedures set forth in this manual. Proper care,
procedures, and tools must be used in handling, lifting, installing, operating, maintaining,
and repairing this equipment, to prevent personal injury and/or property damage.
For the protection of authorized service and maintenance personnel, the pump motor
associated with this equipment should be installed with a lockable disconnect switch
located in close proximity and within sight if the Industrial Water Filter. No service work
should be performed on or near the pump motors, without first ensuring that the pump
motor has been electrically disconnected and locked out.
The re-circulating water system may contain chemicals or biological contaminants that
could be harmful if inhaled or ingested. Accordingly, personnel who may be exposed
directly to the mists produced by water jets or compressed air (should these be used to
clean portions or components of the Industrial Water Filter) should wear half-face
respirators with HEPA filter cartridges, NIOSH/MSHA approved number TC-21C-142/TC-
21C-18.