Davey TYPHOON T-Series Swimming Pool Pumps - Manual (Page 3)

1) Pump does not
prime.
2) Pump supplies
scant flow.
3) Pump noisy.
4) Pump does not
start.
5) Motor makes sound
but does not start.
POSSIBLE FAULTS, THEIR CAUSES AND SOLUTIONS
1 2 3 4 5 POSSIBLE PROBLEM SOLUTIONS
X X Air entry through suction line. Verify condition of connectors and gaskets of suction line.
X Inadequate airtightness of filter cover. Clean the filter cover and verify condition of rubber gasket.
X X Motor turning direction reversed. Reverse 2 phases of the supply.
X Defective mechanical seal. Change mechanical seal.
X X Excessive suction height. Set pump at a suitable level.
X X X Incorrect voltage. Verify the voltage specified on the nameplate and that of the mains.
X No water in prefilter. Fill prefilter with water.
X Suctioning out of water. Set suction in correct position.
X Filter clogged. Clean filter.
X X Diameter of suction line smaller than required. Correctly dimension suction line.
X Discharge clogged. Inspect filter and discharge line.
X Incorrect pump attachment. Attach pump correctly.
X Foreign body in pump. Clean pump and inspect its filter .
X Thermal relay tripped. Reset thermal relay.
X Lack of power. Reset the fuses.
X
If the supply cord is damaged, it must be replaced by the manufacturer or it’s service agent or a similarly qualified person in order to avoid a
hazard.
DAVEY WATER PRODUCTS GUARANTEE FOR AUSTRALIA & NEW ZEALAND
This Davey product is guaranteed to be free of material or manufacturing defects at the time of original
purchase. Should any part fail as a result of such defects within three years of original purchase, the
product will be repaired free of charge.
TERMS AND CONDITIONS
1. This guarantee applies to all states and territories of Australia and New Zealand only and is
subject to the provisions of the Trade Practices Act (Aust.), the Goods and Consumer Protection
Legislation of the various Australian states and the Consumers guarantee Act 1993 (NZ) as
applicable.
2. The guarantee period commences on the date of original purchase of the equipment. Evidence of
this date of original purchase must be provided when claiming repairs under guarantee. It is
recommended you retain all receipts in a safe place.
3. This guarantee covers parts and workshop labour only. Goods should be forwarded, with proof
of date of original purchase, to an Authorised Davey Service Centre freight paid. Any travel and
removal/reinstalling charges for goods repaired infield will be to the owners account. Guarantee
may be denied on goods not readily accessible for service personnel or mounted on exterior
walls above single storey level.
4. This guarantee is subject to due compliance by the original purchaser with all directions and
conditions set out in the Installation and Operating Instructions. Failure to comply with these
instructions, damage or breakdown caused by fair wear and tear, negligence, misuse, incorrect
installation, chemical or additives in the water, inadequate protection against freezing, rain or
other adverse weather conditions, corrosive or abrasive water, lightning or high voltage spikes or
through unauthorised persons attempting repairs are not covered under guarantee. The product
must only be connected to the voltage shown on the nameplate.
5. Without limiting the original purchaser’s entitlements under the Trade Practices Act (Aust.), the
Goods & Consumer Protection Legislation of the various Australian states, or the Consumers
Guarantee Act 1993 (NZ), Davey shall not be liable for any loss of profits or any consequential,
indirect or special loss, damage or injury of any kind whatsoever arising directly or indirectly
from the product or any defect.
6. Where the Trade Practices Act (Aust.), the Goods and Consumer Protection Legislation of the
various Australian states and the Consumers Guarantee Act 1993 (NZ) does not apply. Davey
shall not be liable for any loss of profits or any consequential, indirect or special loss, damage or
injury of any kind whatsoever suffered by the purchaser arising directly or indirectly from the
product or any defect and the purchaser shall indemnify Davey against any claim by any other
person whatsoever in respect of any such loss, damage or injury.
various Acts and this guarantee is to be modified to the extent necessary to give effect to that
intention.
8. Davey may be collecting personal information from you in order to provide you with a service.
Davey Water Products Pty Ltd promises only to use this information in accordance with the
Provisions of the Privacy Act 1988 (Cth) and the Privacy Policy of Davey Water Products Pty
Ltd which is available at davey.com.au.
© Davey Water Products Pty Ltd 2008.
® Davey is a registered trademark of Davey Water Products Pty Ltd.
Motor blocked . R emove the motor and call the Technical Service .