Alto-Shaam Cook - Manual (Page 18)

PG . 16 767-SK/III, 1767-SK/III, 2800-SK/III INSTALLATION / OPERATION / SERVICE MANUAL
Wood Chip Tray
Preparation
Adjust the inside door vents per the individual
cooking procedure selected. Always keep door
vents closed when cooking with the smoking
function. Insert drip pan on the bottom of the
oven cavity.
Wood Chips
Soak one full tray of wood chips in water for 5 to
10 minutes. Shake off excess water, and place the
moistened chips in the wood chip tray of the
smoker oven. Replace the container in the oven.
Press and release power switch O
N
/O
FF
Control Key.
Press and set C
OOK
thermostat to required
cooking temperature.
Press and set T
IME
or P
ROBE
.
Press and set H
OLD
thermostat to required
holding temperature.
The Oven is automatically programmed to
preheat to the set cooking temperature. The
oven will produce an audible signal when
fully preheated.
Prepare product for cooking.
Load product on shelves.
To Set Smoking Time
Press the S
MOKER
Key.
Press the U
P
and D
OWN
A
RROW
K
EYS
to
select the smoke time in minutes.
Press S
TART
.
Note: The sm o k ing tim er activates the
heating elem ent lo cated w ithin the
w o o d chip co ntainer w hen in either a
co o k o r ho ld m o d e. The sm o k e
elem ent w ill no t turn o n d uring
p reheat o r read y m o d es. A full w o o d
chip co ntainer w ill p ro d uce sm o k e
fo r a p erio d o f ap p ro xim ately 1 ho ur,
even tho ugh the tim er can go p ast
o ne ho ur.
To Enter Cold Smoke Mode
Press and release power switch O
N
/O
FF
Control Key.
Press and hold the S
MOKER
Key for a period
of 3 seconds.
To Set Cold Smoke Holding
Temperature
The temperature will default to the last
smoke holding temperature set by the user.
The holding temperature range is
14°F to 205°F (-10°C to 96°C).
To increase this default temperature, press
the H
OLD
K
EY
and press the U
P
A
RROW
to set
a higher default temperature.
To Set Smoking Verification
Temperature ( IF DESIRED )
Press the P
ROBE
K
EY
Press the U
P
and D
OWN
A
RROW
K
EYS
to select the verification temperature. The probe
range is 14°F to 195°F (-10°C to 91°C).
This will incorporate the probe into the cold-
smoking process and the control will alarm if the
temperature exceeds the probe set point.
To Set Smoking Time
Press the S
MOKER
Key.
Press the U
P
and D
OWN
A
RROW
K
EYS
to
select the smoke time in minutes.
Prepare product for smoking.
Place stainless steel tray filled with ice on
shelf above the smoker tray.
Load product on shelves.
Press S
TART
.
Taste preference Minimum Smoking time
Light Smoke Flavor 10 min.
Medium Smoke Flavor 30 min.
Heavy Smoke Flavor 40 min.
Very Heavy Smoke Flavor 60 min.
Extra Heavy Smoke Flavor 80 min.
Hot Smoke Procedure Cold Smoke Procedure
These instructions are basic operational guidelines only.
For complete instructions, see the HALO HEAT
Guide to Low Temperature Cooking and Holding
provided with the oven.
For maximum product tenderizing and to reduce labor
during peak preparation hours, products can be
cooked and held overnight.
O P E R A T I N G I N S T R U C T I O N S
W A R N I N G
THE USE OF IMPROPER
MATERIALS FOR THE SMOKING
FUNCTION COULD RESULT IN
DAMAGE, HAZARD, EQUIPMENT
FAILURE OR COULD REDUCE THE
OVERALL LIFE OF THE OVEN.
DO NOT USE SAWDUST
FOR SMOKING.
DO NOT USE WOOD CHIPS
SMALLER THAN THUMBNAIL SIZE.