Minuteman E Ride 26 SPORT - Manual (Page 5)

5
Table of Contents
Introduction . . . . . . . . . . . . . 2
Preface . . . . . . . . . . . . . . . . . . 2
Proper use . . . . . . . . . . . . . . . 2
Disclaimer. . . . . . . . . . . . . . . . 3
Notes on warranty . . . . . . . . . 4
Acceptance of the machine . . 4
1 Safety Information . . . . . . . . 6
1.1 Safety and Warning Symbols . 6
1.2 General Provisions . . . . . . . . . 7
1.3 Operational Precautions. . . . . 8
1.4 Maintenance Precautions. . . . 9
1.5 Battery and Electrical System
Precautions . . . . . . . . . . . . . 10
1.6 Cleaning Solution Use and Dis-
posal Precautions. . . . . . . . . 11
1.7 Machine Labels . . . . . . . . . . 12
2 Machine Overview . . . . . . . 14
2.1 Front . . . . . . . . . . . . . . . . . . . 14
2.2 Rear . . . . . . . . . . . . . . . . . . . 15
3 Operating Elements . . . . . . 16
3.1 Operating Panel . . . . . . . . . . 16
3.2 Circuit Breaker Panel . . . . . . 20
3.3 Off Aisle Wand Swicth Panel 22
3.4 At the Machine . . . . . . . . . . . 24
4 First Operation . . . . . . . . . . 30
4.1 Instruction. . . . . . . . . . . . . . . 30
4.2 Initial charging procedure . . . 30
4.3 Before Putting into Operation 30
4.4 Start Machine . . . . . . . . . . . . 30
4.5 Operation . . . . . . . . . . . . . . . 31
4.6 Stop Machine . . . . . . . . . . . . 32
4.7 After Work . . . . . . . . . . . . . . 32
4.8 Transporting the machine . . 33
4.9 Tie-down points . . . . . . . . . . 33
5 Operation . . . . . . . . . . . . . . 34
5.1 Method of Operation . . . . . . 34
5.1.1 Brush Deck. . . . . . . . . . . . . . 34
5.1.2 Solution Tank . . . . . . . . . . . . 34
5.1.3 Squeegee. . . . . . . . . . . . . . . 35
5.1.4 Recovery Tank . . . . . . . . . . . 35
5.1.5 Batteries . . . . . . . . . . . . . . . . 35
5.1.6 Drive motor. . . . . . . . . . . . . . 35
5.1.7 Options . . . . . . . . . . . . . . . . . 35
6 Technical Data . . . . . . . . . . 36
7 Maintenance and Care . . . . 38
7.1 Minuteman System Mainte-
nance . . . . . . . . . . . . . . . . . . 38
7.2 Maintenance Document . . . . 39
7.3 Maintenance Schedule. . . . . 40
7.4 Battery Systems . . . . . . . . . . 44
7.4.1 Charge Batteries . . . . . . . . . 45
7.4.2 Charger Specifications . . . . . 45
7.4.3 Drive Batteries . . . . . . . . . . . 45
7.4.4 Remove Batteries. . . . . . . . . 45
7.4.5 Install Batteries. . . . . . . . . . . 45
7.4.6 Disposal of Batteries . . . . . . 45
7.5
Solution tank . . . . . . . . . . . . 46
7.5.1 Fill solution tank . . . . . . . . . . 47
7.5.2 Empty solution tank . . . . . . . 47
7.5.3 Solution Filter . . . . . . . . . . . . 47
7.6
Recovery tank . . . . . . . . . . . 48
7.6.1 Empty recovery tank . . . . . . 49
7.6.2 Clean recovery tank . . . . . . . 49
7.6.3 Clean Suction Filter . . . . . . . 49
7.7
Disc brush deck . . . . . . . . . . 50
7.7.1 Clean Brushes . . . . . . . . . . . 50
7.7.2 Change Brushes . . . . . . . . . 50
7.7.3 Change Roller Bumper. . . . . 50
7.7.4 Change side squeegee . . . . 50
7.7.5 Adjust side squeegee. . . . . . 51
7.8
Squeegee. . . . . . . . . . . . . . . 52
7.8.1 Cleaning the Squeegee . . . . 52
7.8.2 Change Squeegee Blades . . 52
7.8.3 Adjusting the Blades . . . . . . 53
7.8.4 Adjusting lift mechanism . . . 55
7.9
Machine lubrication . . . . . . . 56
8 Troubleshooting. . . . . . . . . 58
Warranty . . . . . . . . . . . . . . . . . . . . . 62