AAON RK-60 - Manual (Page 2)

2
SECTION PAGE NUMBER
OWNER'S INFORMATION …………………………………………………………………………… 03
HEATING / COOLING SYSTEMS …………………………………………………………………… 04
GAS UNIT LIGHTING INSTRUCTIONS …………………………………………………………… 05
PERIODIC INSPECTION PROCEDURES ………………………………………………………… 06
Gas Heating, Cooling, Electric, Steam, Hot Water & Chilled Water Units
SERVICE, TROUBLE SHOOTING & MAINTENANCE ………………………………………… 08
Lubrication
Cleaning
FILTER INSTALLATION / REPLACEMENT ……………………………………………………… 09
SERVICING ……………………………………………………………………………………………… 10
Rooftop Unit Replacement Parts …………………………………………………………… 12
SEQUENCE OF OPERATIONS ……………………………………………………………………… 13
Heating
Cooling
Optional Economizer
VAV Systems …………………………………………………………………………………… 14
Power Exhaust Options
TABLE OF CONTENTS
AAON ®
It is the intent of AAON, Inc. to provide accurate and current specification information. However, in the interest of product improvement,
AAON, Inc. reserves the right to change pricing, specifications and/or design of it's products without notice, obligation or liablity.
© 2000 AAON, Inc., all rights reserved throughout the world.
AAON & AAONAIRE are registered trademarks of AAON, Inc., Tulsa, OK.
P83730 (rev. B • 7-00)
▲
! WARNING
Improper installation, adjustment, alteration, ser-
vice or maintenance can cause property damage,
personal injury or loss of life. Installation and
service must be performed by a qualified in-
staller, service agency or the gas supplier.
▲
! IMPORTANT
The Clean Air Act of 1990 bans the intentional
venting of refrigerant (CFC's and HCFC's) as of
July 1, 1992. Approved methods of recovery,
recycling or reclaiming must be followed. Fines
and/or incarceration may be levied for non-
compliance.
Owner should pay particular attention to the words: NOTE, CAUTION AND WARNING.
NOTES are intended to clarify or make the installation easier. CAUTIONS are given to prevent
equipment damage. WARNINGS are given to alert owner that personal injury and/or equipment
damage may result if installation procedure is not handled properly.