SCT-Germany MONTAGE CLEANER - Manual (Page 2)

Prepared according to Annex II of EC Regulation 1907/2006
Printing Date: 12.12.2010 Revision Date: 12.12.2010 Page 2/5
05. Fire-fighting measures
5.1 Suitable extinguishing media
Co2; Extinction powder; Water jet spray; Alcohol resistant foam; Cool container at risk with water.
5.2 Extinguishing media which shall not be used for safety reasons
High volume water jet
5.3 Special exposure hazards arising from the substance or preparation itself,
combustion products, resulting gases
In case of fire the following can develop:
Oxides of carbon; Toxic pyrolysis products.; Danger of bursting (explosion) when heated; Explosive
vapour/air mixture; Dangerous vapours heavier than air.; In case of spreading near the ground, flashback to
distance sources of ignition is possible.
5.4 Special protective equipment for fire-fighters
In case of fire and/or explosion do not breathe fumes. Protective respirator with independent air supply.
According to size of fire Full protection, if necessary
5.5 Further information
Dispose of contaminated extinction water according to official regulations.
06. Accidental release measures
Refer to point 13. and for personal protection refer to point 8.
6.1 Personal precautions
Remove possible causes of ignition - do not smoke. Ensure sufficient supply of air. Avoid inhalation, and
contact with eyes or skin. If applicable, caution - risk of slipping
6.2 Environmental precautions
Prevent penetration into drains, cellars, working pits or other places in which accumulation could be
hazardous. Prevent surface and ground-water infiltration, as well as ground penetration. If accidental entry
into drainage system occurs, inform responsible authorities.
6.3 Methods for cleaning up
If spray or gas escapes, ensure ample fresh air is available. Without adequate ventilation, formation of
explosive mixtures may be possible. Active substance: Collect using absorbant material (e.g. Universal
binding medium, sand, kieselguhr) and dispose of according to point 13.
07. Handling and storage
7.1 Handling
Tips for safe handling:
See point 6.1
Ensure good ventilation. Avoid inhalation of the vapours. Avoid contact with eyes or skin. Keep away from
sources of ignition - Do not smoke. Take measures against electrostatic charging, if appropriate. Do not use
on hot surfaces. Eating, drinking, smoking, as well as food-storage, is prohibited in work-room. Observe
directions on label and instructions for use. Use working methods according to operating instructions.
7.2. Storage
Requirements for storage rooms and containers:
Not to be stored in gangways or stair wells. Store product closed and only in original packing. Observe special
regulations for aerosols!
Special storage conditions:
See point 10
Store cool Keep protected from direct sunlight and temperatures over 50°C. Store in a well ventilated place.
Observe special storage conditions (in Germany, e.g., in accordance with the regulations in the
"Betriebssicherheitsverordnung").
08. Exposure controls/personal protection
Chemical Name content%: 80-100
WEL-STEL: 2 (II) (AGW)
Chemical Name content%: 1-5
WEL-STEL: 15000 ppm (27400 mg/m³)
(WEL)
Carbon dioxide
WEL-TWA: 5000 ppm (9150 mg/m³) (WEL), 5000 ppm
(9000 mg/m³) (EC) ---
BMGV: ---
Other informations: ---
Other informations: ---
WEL-TWA: 1200 mg/m³ (normal and branched chain
>=C7) (WEL), 600 mg/m³ (AGW) ---
Naphtha (petroleum), hydrotreated heavy
BMGV: ---
Montage Cleaner