Section 3, Turbocharger assembly instal, Section 3 turbocharger assembly installation – Banks Power Twin-Turbo: Forced Induction- Twin Turbos Small Block Chevy User Manual
Page 8

8
96800 v.1.0
1.
Apply a small amount of anti-seize
onto the course threads of the eight
3
⁄
8
" studs. Note: Two of the studs are
shorter.
2.
Install four studs into the turbine
inlet flange on each exhaust manifold.
The short studs are used in the right
front corner of each manifold. See
Figure 3.
3.
Thread two
3
⁄
8
” fine thread hex
nuts onto one of the studs.
4.
Lock the nuts together by turning
them in opposite directions toward
each other. See
Figure 4.
5.
Once the nuts are locked together
use a wrench to snug the stud into the
exhaust manifold flange by turning the
upper nut. (Approx 5-8 ft-lbs).
6.
Loosen the nuts by turning them in
the opposite direction and remove
them from the stud.
7.
Repeat Steps 3 – 6 for the
remaining seven studs.
8.
Each exhaust manifold is provided
with a
1
⁄
4
" NPT pipe port for an
exhaust gas temperature gauge probe
(pyrometer). These ports are on the
side of the manifold below the turbo
flange. If a pyrometer probe is not
installed, make sure a provided
1
⁄
4
"
pipe plug is installed in this port on
each manifold. Use Anti-seize on the
pipe threads. See
Figure 5.
9.
Remove the turbochargers from
their packaging. Carefully check the
turbochargers for any packing debris.
Remove any debris found in the
assembly.
Note: Debris in the turbocharger can
damage it and the engine if not
removed.
10.
Install the two turbochargers onto
the two exhaust manifolds. The
turbine outlet should face the rear of
Section 3
TURBOCHARGER ASSEMBLY INSTALLATION
Figure 3
- Ford Trucks: (Diesel ’94 - 97 7.3L Power Stroke) Tuner- Big Hoss Module (6 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Intake- Ram-Air Intake system '03-07 F-250-350-450 pickup (20 pages)
- Ford Trucks: (Gas ’04 - 08 F-150 V6 & V8) Exhaust- Monster Exhaust, Dual out the back exit '04-10 F-150 4.2L, 4.6L & 5.4L (Non-Heritage models) (12 pages)
- Ford Trucks: (Diesel ’99 - 03 7.3L Power Stroke) Forced Induction- Big Head Wastegate Actuator '99-03 F-250 & F-350 pickup (4 pages)
- Chevy_GMC Trucks: Duramax LLY (Diesel ’04 - 05 6.6L) Speed Control- Banks Brake w_ Switch (20 pages)
- Toyota Trucks: (Gas ’05 - 12 4.0L Tacoma) Exhaust- Monster Exhaust, Single side exit 2013 Toyota Tacoma 4.0L (8 pages)
- Chevy_GMC Trucks: Duramax LLY-LBZ (Diesel ’06 - 07 6.6L) Tuner- Six-Gun Diesel Tuner '06 -07 (PDA) Compatible with Optional PowerPDA & Speed-Loader (28 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Exhaust- Monster Exhaust, Single out the back '04-07 325 HP Dodge 5.9L HO Cummins Trucks, Including Mega Cab (8 pages)
- Dodge Trucks: (Diesel ’07 - 12 6.7L Cummins) Exhaust- Monster Exhaust, Split-Dual Quad Tip ,side exit '07-09 Including Mega Cab (12 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Exhaust- Monster Exhaust, Single Passenger side exit, F-250_F-350 '03-07 Pickup Trucks and Excursions (16 pages)
- Dodge Trucks: (Gas ’02 - 10 5.7L HEMI & 4.7L) Exhaust- Monster Exhaust '06-08 Ram 1500 Hemi ('06-08) RCSB_CCSB_CCLB & ('06-07) Mega Cab (8 pages)
- Ford Trucks: (Diesel ’99 - 03 7.3L Power Stroke) Intake- Ram-Air Intake System '99-03 (16 pages)
- Dodge Trucks: (Diesel ’94 - 98 5.9L Cummins) Intake- Ram-Air Intake System '98-02 (12 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Tuner- Six-Gun Diesel Tuner w optional Speed-Loader Module, (325 HP Dodge 5.9L Cummins 600 (24-valve) Trucks) '04-05 For use with Six-Gun Switch (28 pages)
- Ford Trucks: (Diesel ’08 - 10 6.4L Power Stroke) Exhaust- Monster Exhaust, Single Passenger side exit '08-10 F-250_ F-350 (16 pages)
- GM Motorhomes: (Gas ’01 - 10 8.1L Workhorse) PowerPack & Stinger systems '01-04 Class-A MH, P-series (14 pages)
- Ford Trucks: (Gas ’09 - 12 F-150 5.0, 5.4 & 6.2L) Exhaust- Monster Exhaust, Single Passenger side exit '09-10 F-150 5.4L SuperCrew Cab & F-150 Raptor 6.2L SuperCab (8 pages)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Speed Control- Compressor Relocation Kit Required for Ram-Air Intake System (8 pages)
- Ford Trucks: (Diesel ’94 - 97 7.3L Power Stroke) Speed Control- Banks Exhaust Brake '94-97 (16 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Interface- PowerPDA Ford (03-09), Chevy (01-08), Dodge (03-07) (44 pages)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Power Systems- PowerPack & Stinger Systems w_ EconoMind (LB7 & LLY) '01-05 (PDA) Compatible w_ Optional PowerPDA (45 pages)
- Ford Trucks: (Diesel ’08 - 10 6.4L Power Stroke) Tuner- Six-Gun Diesel Tuner & SpeedBrake, For use with Banks iQ '08-10 Compatible with PowerPDA (36 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Intake- High-Ram Intake '03-07 w_Banks Boost Tube (12 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) PowerPack & Stinger w_EconoMind '03-05 For use with PowerPDA (40 pages)
- Ford Trucks: (Diesel ’08 - 10 6.4L Power Stroke) Intake- Ram-Air Intake System '08-10 F-250_ F-350_ F-450 (16 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Tuner- Six-Gun Diesel Tuner (235, 250, 305 HP Dodge 5.9L Cummins (24-valve) Trucks) '03-04 For use with Six-Gun Switch (36 pages)
- Ford Trucks: (Gas ’87 - 97 7.5L EFI) Power Systems- Stinger system '87-96 SC, EC & CC (For Use w_ 460 EFI Engine) (8 pages)
- Cummins Motorhomes: (Diesel ’93 - 98 B5.9L & C8.3L) PowerPack & Stinger systems w_Twin Ram Manifold 5.9L, 190-210-230-hp rated (20 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Intake- Techni-Cooler Charge Air Cooler ('03-07) (12 pages)
- Chevy_GMC Trucks: Gas ’99 - 14 4.3,4.8,5.3,6.0,6.2,8.1 Exhaust- Torque Tubes System '99-08 GM 4.8L, 5.3L, 6.0L & '09-10 GM 5.3L Pickups & SUVs (8 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Intake- High-Ram Air Intake '03-07 (12 pages)
- Dodge Trucks: (Diesel ’94 - 98 5.9L Cummins) Power Systems- Git-Kit; '94-97 (1 page)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Tuner- Six-Gun Diesel Tuner with optional Speed-Loader Module '01-04 For use with Six-Gun Switch (24 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) Speed Control- Banks Brake with CBC-SmartLock '04-07 (52 pages)
- Chevy_GMC Trucks: Diesel ’93 - 96 6.5L Power Systems- Stinger System '93-early '94 (non-cat) Pickups w_ factory turbo option (10 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Tuner- Six-Gun Diesel Tuner w_ optional Speed-Loader Module For use with Six-Gun switch Only (28 pages)
- Ford Trucks: (Diesel ’11 - 14 6.7L Power Stroke) Exhaust- Monster Exhaust, Split-Dual, side exits '11 F-250_ F-350_ F-450 (12 pages)
- Dodge Trucks: (Diesel ’98 - 02 5.9L Cummins ISB) Tuner- Big Hoss Diesel Tuner (does not connect to pump wire) (16 pages)
- Dodge Trucks: (Diesel ’03 - 07 5.9L Cummins) PowerPack & Stinger w_EconoMind '06-07 For use with PowerPDA (36 pages)
- Ford Trucks: (Diesel ’03 - 07 6.0L Power Stroke) Power Systems- PowerPack & Stinger '03-07 Compatible w_ Optional Banks iQ (42 pages)
- Ford Trucks: (Diesel ’83 - 93 6.9 & 7.3L) Forced Induction — Sidewinder Turbo System (1st Generation) 6.9_7.3L Ford (39 pages)
- Dodge Trucks: (Diesel ’07 - 12 6.7L Cummins) Exhaust- Monster Exhaust, Split-Dual, side exits '07-10 including Mega Cab (12 pages)
- Ford Trucks: (Diesel ’99 - 03 7.3L Power Stroke) Exhaust- Monster Exhaust, Single Passenger side exit (w_ cat) '99-03 F-250 & F-350 (20 pages)
- Chevy_GMC Trucks: Duramax LB7 (Diesel ’01 - 04 6.6L) Intake- Ram-Air Intake Super-Scoop '03-07 (12 pages)
- Dodge Trucks: (Diesel ’98 - 02 5.9L Cummins ISB) Intake- Heater Delete Kit '98-07 (1 page)