Razor SPORTMOD 15130412 - Manual (Page 8)

7
Vehicle does not run
Vehicle was running but
suddenly stopped
Short run time (less than
30 minutes per charge)
Vehicle runs sluggishly
Problem Possible Cause Solution
Undercharged battery
Charger is not working
Loose wires or connectors
Blown fuse
Undercharged battery
Battery is old and will not accept
full charge
Brakes are not adjusted properly
Driving conditions are too stressful
Tires are not properly inflated
Vehicle is overloaded
Charge the battery. A new battery should have been charged for at least 12
hours before using the vehicle for the first time and up to 8 hours after each
subsequent use.
Check all connections. Make sure the charger port is tightly plugged into
the charging port on the Sport Mod, and that the charger is plugged into the
wall.
Make sure power flow to the wall outlet is on.
You may check to see if your charger is working by using a volt meter or
asking your local Razor authorized service center to test your charger for you.
Check all wires and connectors to make sure they are tight.
If the motor is overloaded it could blow the fuse. Replace fuse. Refer to
instructions on page 6.
An excessive overload, such as too heavy a rider or too steep a hill, could
cause the motor to overheat. If the Sport Mod suddenly stops running,
wait a few seconds and then push the breaker to reset the circuit. Correct the
conditions that caused the breaker to trip and avoid repeatedly tripping
the breaker.
Charge the battery. A new battery should have been charged for at least 12
hours before using the vehicle for the first time and up to 8 hours after each
subsequent use.
Check all wires and connectors. Make sure the battery connector is tightly
plugged into the charger connector, and that the charger is plugged into
the wall.
Make sure power flow to the wall outlet is on.
Even with proper care, a rechargeable battery does not last forever. Average
battery life is 1 to 2 years depending on vehicle use and conditions. Replace
only with a Razor replacement battery.
Refer to adjusting the brakes instructions on page 4.
Use only on solid, flat, clean and dry surfaces such as pavement or level
ground.
The tires are inflated when shipped, but they invariably will lose some
pressure between the point of manufacturing and your purchase.
Refer to tire inflation instructions on page 4.
Make sure you do not overload the vehicle by allowing more than one rider
at one time, exceeding the 220 lb. maximum weight limit, going up a hill
or towing objects behind the vehicle. If the vehicle is overloaded, the
circuit breaker may trip and shut off power to the motor. Correct the driving
conditions that caused the overload, wait a few seconds, and then push the
breaker to reset the circuit. Avoid repeatedly tripping the circuit breaker.
TROUBLESHOOTING GUIDE