Warning, Final assembly, 3a 3b – Napoleon Fireplaces NZ-26 User Manual
Page 14
W415-0676 / 03.14.08
14
Attach the handle as shown so that
when the door is closed, the handle
will be centred in the slot located on the
fi replace front. To achieve this you may
have to experiment (on the upper and
lower screws) with one of the variations
shown. Tighten securely.
FIGURE 24
FINAL ASSEMBLY
ATTACHING THE HANDLE
Place gasket rope along the upper ledge of the air chamber
and on the top of the rear bricks. The top and bottom fl ame
spreaders come taped together. This tape will burn away in the initial
fi ring of the unit. On subsequent brick removals, the bottom fl ame
spreader must be taped to the top spreader to ease top brick and
baffl e removal and to avoid damaging the fi bre baffl es.
1
1
2
GASKET ROPE LOCATION
GASKET ROPE LOCATION
REAR
REAR
BRICKS
BRICKS
Unscrew and remove the front tube retainer. Note that the fi rst
tube retainer also holds the side brick in place. Slide the tube
either to the left or right and remove. Remove the two middle
tubes in the same fashion.
The fi replace is shipped with the fi rebricks in place. Top fi rebricks,
fi bre baffl es and gasket rope are not installed.
TOP FIREBRICK AND BAFFLE
INSTALLATION
FIBRE BAFFLE
FIBRE BAFFLE
TUBE
TUBE
TOP FIREBRICK
TOP FIREBRICK
TUBE
TUBE
RETAINER
RETAINER
FIGURE 23
FIGURE 25
FIGURE 26
FIGURE 26
FIGURE 27
FIGURE 27
1
2
Insert the left baffl e, then the left top fi rebrick. Repeat using
the right baffl e and brick.
The baffl es are made of a brittle material. Care must be taken
not to bend or force them.
Replace the three front tubes. Position the center edg-
es of both baffles and bricks until they lie snugly together.
Slide the baffl e support bracket into place along the front of the unit
between the front tube and the two top fi rebricks.
3
TOP FLAME SPREADER
TOP FLAME SPREADER
BOTTOM FLAME SPREADER
BOTTOM FLAME SPREADER
FIBRE BAFFLE (1 OF 2 SHOWN)
FIBRE BAFFLE (1 OF 2 SHOWN)
TOP FIREBRICK (1 OF 2 SHOWN)
TOP FIREBRICK (1 OF 2 SHOWN)
3a
3b
BAFFLE SUPPORT BRACKET
BAFFLE SUPPORT BRACKET
FIGURE 28
FIGURE 28
FIGURE 29
FIGURE 30
FIGURE 30
4
!
WARNING
Operation of the fi replace without the top fi rebricks and the
baffl es can result in excessive temperatures that could dam-
age the fi replace, chimney and the surrounding enclosure.