Kohler Courage XTR-6 - Manual (Page 8)

8
Electric Start (XTR-7 Only)
ŗǯȱ ˜ŸŽȱžŽ•ȱœ‘žȬ˜ěȱŸŠ•ŸŽȱ˜ȱ‘ŽȱON position (if
Žšž’™™ŽǼǯȱŽŽ›ȱ˜ȱ’ž›ŽȱŚǯ
Řǯȱ ž›—ȱ‘Žȱ’—’’˜—ȱœ ’Œ‘ȱ˜ȱ‘ŽȱON position (if
equipped). Refer to the operating instructions of
the equipment this engine powers.
3. Start the engine by activating key switch; release
as soon as engine starts.
NOTE: Do not crank the engine continuously for
–˜›Žȱ‘Š—ȱśȱœŽŒ˜—œȱŠȱŠȱ’–Žǯȱȱ‘ŽȱŽ—’—Žȱ
does not start, wait 30 seconds before
ŠĴŽ–™’—ȱ˜ȱ›ŽœŠ›ǯȱŠ’•ž›Žȱ˜ȱ˜••˜ ȱ‘ŽœŽȱ
guidelines may damage or overheat the
starter motor.
Śǯȱ —ŒŽȱ‘ŽȱŽ—’—ŽȱœŠ›œǰȱŠ“žœȱ’ȱ˜ȱ‘ŽȱŽšž’™–Ž—ȱ
manufacturer's recommended operating speed (if
adjustable).
Recoil Start
ŗǯȱ ˜ŸŽȱ‘ŽȱžŽ•ȱœ‘žȬ˜ěȱŸŠ•ŸŽȱ˜ȱ‘ŽȱON position
ǻ’ȱŽšž’™™ŽǼǯȱŽŽ›ȱ˜ȱ’ž›ŽȱŚǯ
Řǯȱ ž›—ȱ‘Žȱ’—’’˜—ȱœ ’Œ‘ȱ˜ȱ‘ŽȱON position (if
equipped). Refer to the operating instructions of
the equipment this engine powers.
3. Pull the starter handle straight out with a smooth,
steady motion.
NOTE: Extend the starting rope periodically and
check its condition. If the rope is frayed, have it
replaced immediately by a Kohler Authorized
Service Center.
Śǯȱ —ŒŽȱŽ—’—ŽȱœŠ›œǰȱŠ“žœȱ’ȱ˜ȱ‘ŽȱŽšž’™–Ž—ȱ
manufacturer's recommended operating speed (if
adjustable).
WARNING: Accidental Starts!
Before extending and checking the retractable starter rope,
remove the spark plug lead to prevent the engine from
starting accidentally.
Primer Bulb Start (If Equipped)
ŗǯȱ ˜ŸŽȱžŽ•ȱœ‘žȬ˜ěȱŸŠ•ŸŽȱ˜ȱ‘ŽȱON position (if
Žšž’™™ŽǼǯȱŽŽ›ȱ˜ȱ’ž›ŽȱŚǯ
Řǯȱ ž›—ȱ‘Žȱ’—’’˜—ȱœ ’Œ‘ȱ˜ȱ‘ŽȱON position. Refer
to the operating instructions of the equipment
this engine powers.
řǯȱ ‘Ž—ȱ‘Žȱ˜žœ’ŽȱŽ–™Ž›Šž›Žȱ’œȱŠ‹˜ŸŽȱśśǚȱ
ǻŗřǚǼǰȱ™›Žœœȱȱ˜ȱ™›’–Ž›ȱ‹ž•‹ȱ‘›ŽŽȱ’–Žœȱ
before starting. When outside temperature is
‹Ž•˜ ȱśśǚȱǻŗřǚǼǰȱ™›Žœœȱȱ˜ȱ™›’–Ž›ȱ‹ž•‹ȱ
꟎ȱ’–Žœȱ‹Ž˜›ŽȱœŠ›’—ǯȱŽŽȱ’ž›ŽœȱŗŖȱŠ—ȱŗŗǯ
Primer Bulb
Figure 10. Primer Bulb.
Figure 11. Primer Bulb Quick Reference Table.
NOTE: It is important to press the CENTER of the
red primer bulb so the air hole is covered,
ensuring proper pressure.
NOTE: Pressing the primer bulb more times than
›ŽŒ˜––Ž—Žȱ ’••ȱ̘˜ȱŽ—’—Žǰȱ–Š”’—ȱ
œŠ›’—ȱ–˜›Žȱ’ĜŒž•ǯ
Śǯȱ —ŒŽȱ‘ŽȱŽ—’—ŽȱœŠ›œǰȱŠ“žœȱ’ȱ˜ȱ‘ŽȱŽšž’™–Ž—ȱ
manufacturer's recommended operating speed (if
adjustable).
śǯȱ ˜ȱ›ŽœŠ›ȱŠȱ Š›–ȱŽ—’—Žǰȱ—˜ȱ™›’–’—ȱ’œȱ›Žšž’›Žǯ
Manual Choke Start
ŗǯȱ ˜ŸŽȱžŽ•ȱœ‘žȬ˜ěȱŸŠ•ŸŽȱ˜ȱ‘ŽȱON position (if
Žšž’™™ŽǼǯȱŽŽ›ȱ˜ȱ’ž›ŽȱŚǯ
Řǯȱ ž›—ȱ‘Žȱ’—’’˜—ȱœ ’Œ‘ȱ˜ȱON (refer to the
operating instructions of the equipment this
engine powers).
3. Turn the ignition switch to ON (refer to the
operating instructions of the equipment this
engine powers).
Śǯȱ ˜ȱœŠ›ȱŠȱŒ˜•ȱŽ—’—Žǰȱ–˜ŸŽȱ‘›˜Ĵ•ŽȦŒ‘˜”Žȱ•ŽŸŽ›ȱ
to FAST/CHOKE ON position. To start a warm
engine, no choke is required.
Cold Engine: Start as follows
Outside temperature
Š‹˜ŸŽȱśśǚȱǻŗřǚǼȽ Primer Choke
3 pumps ON
Outside temperature
‹Ž•˜ ȱśśǚȱǻŗřǚǼ Primer Choke
śȱ™ž–™œ ON
Warm Engine: Do not use primer