Multiquip MQ Power 1000 kW Containerized Diesel Generator Set EGC1000C - Manual (Page 3)

1000 kW Containerized
Diesel Generator Set
DGC2020 Digital Genset Controller
Derating (60Hz)
The engine power available up to 4958 ft.
at temperatures up to 104
o F and up to
4433 ft. at 122°F at standby rating, without
derating. For operation at higher altitudes
and ambient temperatures, the power
sh ould b e derated a ccording to the
following factors:
Altitude
Ambient
Temperature
Above 4958 ft.
derate at 3.4%
per 1000 ft. up to
9843 ft. Derate
an additional 9%
per 1000 ft.
above 9843 ft.
Above 122°F,
derate an
additional
15% per 18°F
Fuel System
Recommended Fuel ASTM-D975/No.1 & No.2-D
Filter Micron Size 2
Total Fuel Flow 150 gal./hr. (568 L/Hr.)
Fuel Consumption
Diesel at % of Load gal/hr L/hr
25% 19.3 7.3
50% 36.0 136
75% 52.6 199
100% 69.3 262
Lubrication System
Type Full Pressure
Oil Filters 4 Spin-on Full Flow
Oil Pressure at Rated Speed 45-56 psi (310-386 kPa)
Oil Capacity with Filters 35 gal (132 L)
■ Local and Remote Generator Control
■ Automatic and manual starting and stopping
■ Engine and Generator Protection
■ Programmable Analog Engine Senders
■ ECU Communications via SAE J1939
■ 16 Programmable Contact Inputs
■ Programmable Logic
■ Automatic Transfer Switch Control (Mains Failure)
■ Integrated RS485 Modbus Connection
■ Auto Synchronizing
■ Event recording
Monitoring
■ Engine RPM
■ Engine run time
■ Generator voltage
■ Generator current
■ Generator frequency
■ Oil pressure
■ Battery voltage
■ Fuel level measurements
■ Running Hour Meter
■ Coolant temperature
■ Generator under/over voltage alarm/shutdown
■ Generator under/over frequency alarm/shutdown
■ Over Current alarm/shutdown
■ Warm up and cooling functions
■ Maintenance timer
Digital Controller Features
EGC1000C Rev 3
Cooling System
Exhaust Manifold Type Dry
Radiator Design Standard Horizontal
Coolant Capacity - Engine Only 37 gal. (140 L)
Water Pump Design/Type Belt Driven, Centrifugal
Coolant Flow 100 gal/min (378 L/min)
Heat Rejection to Coolant (Standby) 40600 Btu/min (715 kW)
Thermostat Range 180-200°F (82-93°C)