Minuteman UPS CPE 2000 - Manual (Page 2)

1
Table of Contents
Important Safety Instructions .................................................................2
1. Introduction ..........................................................................................5
1.1. The General Characteristics ...........................................................6
1.2. The Advanced Technical Characteristics........................................6
2. Introduction to the Front and Rear Panel..........................................7
2.1. Front Panel Display Explanation .....................................................7
2.2. Rear Panel Explanation...................................................................8
2.2.1. General Explanation ...............................................................9
2.2.2. Terminal Block Explanation ....................................................10
2.3. Communication Port and PP Contact Card Explanation.................10
2.3.1. The RS232 Interface Settings.................................................10
2.3.2. The Pin Assignments of the RS232 Port ................................10
2.3.3. The Pin Assignments of the PP Contact Card........................11
3. Installation and Operation...................................................................11
3.1. Unpacking .......................................................................................11
3.2. Selecting Installation Position .........................................................11
3.3. Connecting the Batteries.................................................................12
3.4 Connecting the Equipment...............................................................13
3.5. Storage Instructions ........................................................................13
3.6. Option Slot.......................................................................................13
4. The Working Principle of the UPS......................................................14
4.1. When Utility is Normal .....................................................................14
4.2. When Utility is Abnormal .................................................................14
4.3. Overload Condition..........................................................................15
4.4. Inverter is not Functioning...............................................................16
4.4.1. Output Short-Circuit operating in the On-Line Mode ..............16
4.4.2. Output Short-Circuit operating in the Bypass Mode ...............16
4.5. Inverter Over-Temperature .............................................................16
4.6. Inverter Over-Current and Output Voltage Out of Tolerance..........16
5. Maintenance Guide ..............................................................................17
5.1. System Block...................................................................................17
5.2. Troubleshooting...............................................................................17
5.3. Maintenance....................................................................................18
5.4. Replacing the Batteries ...................................................................19
5.5. Battery Replacement Procedure .....................................................20
6. Power Monitoring Software Installation Guide.................................24
6.1. Hardware Installation.......................................................................24
6.2. Software Installation ........................................................................24
Appendix...................................................................................................27
A.1. Specifications..................................................................................27
A.2. Obtaining Service............................................................................29
A.3. Limited Warranty.............................................................................30
A.4. Declaration of Conformity ...............................................................31
© Copyright Para Systems, Inc., 2005