Basic service parts, Fig. 22 basic service parts, Operation and service information – E-Z-GO 602080 User Manual
Page 32: Owner’s manual and service guide

OPERATION AND SERVICE INFORMATION
Page 16
Owner’s Manual and Service Guide
Read all of manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings
** First occurrence only
#
More frequently in dusty conditions
To perform service that is listed in this schedule but not described in this manual, contact a local Service Representative
or see Repair and Service Manual for this vehicle.
Some maintenance items must be serviced more frequently on vehicles used under severe driving conditions.
BASIC SERVICE PARTS
To order parts, SERVICE PARTS Department contact
information is as follows:
In USA, Phone: 1-800-241-5855; Fax: 1-800-448-8124
Outside USA, Phone: 010-1-706-798-4311; Fax: 010-1-
706-771-4609
E-Z-GO Division of TEXTRON, Inc., 1451 Marvin Griffin
Road, Augusta, Georgia USA 30906-3852
ITEM
BEFORE
EACH
USE
WEEKLY
EVERY
20
HOURS
EVERY
50
HOURS
EVERY
100
HOURS
EVERY
200
HOURS
EVERY
300
HOURS
EVERY
500
HOURS
Tie Rods/Linkages
Check
X
Rear Axle
Check
X**
X
Replace
X
Muffler/Exhaust
Check
X
Spark Arrester
Clean
X
Front Axle
Check
X**
X
Front Knuckles
Check
X
Front Struts
Check
X
Front Wheel Alignment
Check
X
Rear Shock Absorbers
Check
X
Fuel Tank
Clean
X
Throttle/Governor Linkage
Check
X
Hardware And Fasteners
Check
X
Tighten
X
Battery
Clean
X
Drive Belt
Check
X
Front Wheel Bearings
Check
X
Drive shafts
Lubricate
X
C.V.Joints and Boots
Check
X
Fig. 21 Periodic Service Schedule
Air Filter Element
72944-G01
Oil Filter
15400-POH-305PE
Spark Plugs
ZGR5A (NGK)
J16CR-U (DENSO)
Optional Alternator Belt
73561-G01
CVT Belt
73965-G01
Fuse
15 amp (P/N 35212-G01)
20 amp (P/N 35212-G02)
7.5 amp (P/N 35212-G05)
Headlight Bulb
20209-G3
Tail Light Bulb
#1157 (P/N 21759-G1)
Fig. 22 Basic Service Parts