Thermo Pride Spirit Gas TG8S Single Stage PSC 80% User Manual
Page 32
Subject to change without notice. Published in U.S.A.
998491-UIM-B-1013
Copyright © 2013 by Johnson Controls, Inc. All rights reserved.
Supersedes: 998491-UIM-A-0313
York International Corp.
5005 York Drive
Norman, OK 73069
Natural Gas
LP Gas (Requires LP conversion kit)
LP Conversion Kit Installed By
Supply static
after evaporator coil (in w.c.")
Return Static (in w.c.")
before filter
Total External Static Pressure
Blower Speed Selected
Supply Air Dry Bulb Degrees F
Temperature Drop Degrees F
Return Air Dry Bulb Degrees F
Supply Air Dry Bulb Degrees F
Return Air Wet Bulb Degrees F
Supply Air Wet Bulb Degrees F
Outside Air Dry Bulb Degrees F
Temperature Drop Degrees F
Blower Performance Data Chart Cooling CFM
Installation debris disposed of and furnace area cleaned up?
Explain operation of system to equipment owner
Blower Speed Selected (PSC)
Red (Low)
Yel (Med Low)
Blue (Med High)
Black (High)
Explain the importance of regular filter replacement and equipment maintenance
Gas Side
Air Side: System External Static Pressure
Owner Education
Additional Job Detail
Supply static
before evaporator coil (in w.c.")
Calculated input in btuh - clock the gas meter (Nat Gas Only)
Manifold Gas Pressure (in. w.c.")
Inlet Gas Pressure (in. w.c.")
LP Gas Conversion Kit Part # Used
Burner flame inspected -- flames are blue and extending directly into the primary heat exchanger cells
Return Static (in w.c.")
after filter (furnace side)
Air Side: Heating
Air Side: Cooling
Air Side: Continuous Fan
Clean Up
Give owner the owner's manual provided
Gas Type
Explain thermostat use and programming (if applicable) to owner
Cycle Test
Operate the furnace through several heating cycles from the thermostat, noting and correcting any problems
Operate the furnace through continuous fan cycles from the thermostat, noting and correcting any problems
Operate the furnace through cooling cycles (as applicable), noting and correcting any problems
Gray (Med)
Blower Speed Selected (Standard ECM)
Red (Low)
Yel (Med Low)
Blue (Med High)
Black (High)
Blower Speed Selected (PSC)
Red (Low)
Yel (Med Low)
Blue (Med High)
Black (High)
Gray (Med)
Blower Speed Selected (Standard ECM)
Red (Low)
Yel (Med Low)
Blue (Med High)
Black (High)
Blower Speed Selected (PSC)
Red (Low)
Yel (Med Low)
Blue (Med High)
Black (High)
Gray (Med)
Blower Speed Selected (Standard ECM)
Red (Low)
Yel (Med Low)
Blue (Med High)
Black (High)