All Power APGG4000 - Manual (Page 8)

29
Installation
NOTE: PRIOR TO POWERING TOOLS AND EQUIPMENT MAKE SURE THE
GENERATOR’S RATED VOLTAGE, WATTAGE AND AMPERAGE CAPACITY IS
ADEQUATE TO SUPPLY ALL ELECTRICAL LOADS THAT THE UNIT WILL
POWER. IF POWERING EXCEEDS THE GENERATOR’S
CAPACITY, IT MAY BE
NECESSARY TO GROUP ONE OR MORE OF THE TOOLS AND/OR EQUIPMENT
FOR CONNECTION TO A SEPARATE GENERATOR.
Electrical and other permits may be required for the installation of emergency power systems.
Investigate your local building and electrical codes before installing this unit. Installation must be
completed by licensed contractors.
WARNING! THE GENERATOR WEIGHS APPROXIMATELY 100 POUNDS. USE
CARE AND THE PROPER LIFTING OR HOISTING EQUIPMENT WHEN MOVING
IT TO THE INSTALLATION LOCATION. ALWAYS CONNECT HOIST LINES TO
THE FRAME OF THE GENERATOR.
General Location
• Make sure to locate and install the generator outdoors where cooling air is readily available.
• Install the generator so that the air inlets and outlets are not blocked by obstructions such as
bushes, trees, or snow drifts. Locating it in the path of heavy winds or snowdrifts may require
the placement of a barrier for protection. In normal weather conditions, the air vent should face
the prevailing wind direction.
• Install the generator on a concrete slab or other area where rain drainage or flood waters can
not reach it.
• Generator placement should allow four feet of access to all sides for maintenance.
• Place the generator as close as possible to the electrical tools and equipment being powered to
reduce the length of extension cords.
Owner’s Manual
30
Installation (cont’d)
Supporting and Mounting
Mount the generator on a concrete slab capable of supporting the weight of the generator. The
slab must extend on all sides beyond the frame by at least one foot. Contact a cement contractor
for slab specifications if necessary. Attach the frame to the concrete slab using 3/8” diameter
expansion anchor bolts (not supplied).
Grounding
NOTE: IT IS RECOMMENDED THAT ONLY A TRAINED AND LICENSED
ELECTRICIAN PERFORM THIS PROCEDURE
Connect a #6 AWG grounding wire (not included) from the ground connector (8) on the generator
to a grounding rod (not included) that has been driven at least 24 inches deep into the earth. The
grounding rod must be an earth-driven copper or brass rod (electrode) which can adequately
ground the generator.
4000W Generator
> .LULYH[VY
*VTWSPHUJL
<50;,+ :;(;,: ,5=09654,5;(3 796;,*;065 (.,5*@
>(:/05.;65 +*
4VKLS @LHY *LY[PMJH[L VM *VUMVYTP[`
‹4HU\MHJ[\YLY! Jiangsu Jiangdong Group Co., Ltd.
‹*LY[PMPJH[L 5\TILY! JDG-NRSI-10-09
‹ ,MMLJ[P]L +H[L! 12/23/2009
‹+H[L 0ZZ\LK! 12/23/2009
4LYY`SPU AH^4VU +PYLJ[VY *VTWSPHUJLHUK0UUV]H[PVU:[YH[LNPLZ+P]PZPVU 6MMPJL VM
;YHUZWVY[H[PVU HUK (PY 8\HSP[`
7\YZ\HU[ [V :LJ[PVU VM *SLHU (PY (J[ <:* ZLJ[PVU HUK *-9 HUK Z\IQLJ[ [V
[OL [LYTZ HUK JVUKP[PVUZ WYLZJYPILK PU [OVZL WYV]PZPVUZ [OPZ JLY[PMPJH[L VM JVUMVYTP[` PZ OLYLI`
PZZ\LK MVY [OL MVSSV^PUN ZTHSS UVUYVHK LUNPUL MHTPS` TVYL M\SS` KLZJYPILK PU [OL KVJ\TLU[H[PVU
YLX\PYLK I` *-9 HUK WYVK\JLK PU [OL Z[H[LK TVKLS `LHY
;OPZ JLY[PMPJH[L VM JVUMVYTP[` JV]LYZ VUS` [OVZL UL^ ZTHSS UVUYVHK LUNPULZ ^OPJO JVUMVYT PU
HSS TH[LYPHS YLZWLJ[Z [V [OL KLZPNU ZWLJPMPJH[PVUZ KLZJYPILK PU [OL KVJ\TLU[H[PVU YLX\PYLK I`
*-9 HUK ^OPJO HYL WYVK\JLK K\YPUN [OL TVKLS `LHY Z[H[LK VU [OPZ JLY[PMPJH[L ;OPZ JLY[PMPJH[L
VM JVUMVYTP[` KVLZ UV[ JV]LY ZTHSS UVUYVHK LUNPULZ PTWVY[LK WYPVY [V [OL LMMLJ[P]L KH[L VM [OL
JLY[PMPJH[L
0[ PZH[LYT VM [OPZ JLY[PMPJH[L [OH[ [OL THU\MHJ[\YLY ZOHSS JVUZLU[ [V HSS PUZWLJ[PVUZ KLZJYPILK PU
*-9 HUK HUK H\[OVYPaLK PUH^HYYHU[ VY JV\Y[ VYKLY -HPS\YL [V JVTWS` ^P[O
[OL YLX\PYLTLU[Z VM Z\JOH^HYYHU[ VY JV\Y[ VYKLY TH` SLHK [V YL]VJH[PVU VY Z\ZWLUZPVU VM [OPZ
JLY[PMPJH[L MVY YLHZVUZ ZWLJPMPLK PU *-9 0[ PZ HSZVH[LYT VM [OPZ JLY[PMP JH[L [OH[ [OPZ JLY[PMPJH[L
TH` IL YL]VRLK VY Z\ZWLUKLK VY YLUKLYLK ]VPK HI PUP[PV MVY V[OLY YLHZVUZ ZWLJPMPLK PU *-9
7HY[
;OPZ JLY[PMPJH[L KVLZ UV[ JV]LY ZTHSS UVUYVHK LUNPULZ ZVSK VMMLYLK MVY ZHSL VY PU[YVK\JLK VY
KLSP]LYLK MVY PU[YVK\J[PVU PU[V JVTTLYJL PU [OL <: WYPVY [V [OL LMMLJ[P]L KH[L VM [OL JLY[PMPJH[L
:4(33 56596(+ ,5.05, -(403@! AJDGS.1961GA
Type 4-cycle OHV air-cooled recoil start
Displacement 208cc
Oil capacity 0.63 quart (0.6liter)
EPA approved yes
Current Output 120V AC @ 27.5A 60Hz
Continuous/rated Wattage 3,300
Peak Wattage 4,000
Outlet Four 120V outlets, One 120V twist-lock
32
Specifications
AC electrical
DC electrical
12V 8.3 A
Gasoline engine
Fuel
Type Unleaded gasoline
Capacity 4 gallons
Running time 8 hours (approx.) on 1/2 load
Fuel gauge included
Weight
Approximate weight 107 lbs.
Owner’s Manual