Dixon 8000D - Manual (Page 40)

40
1
. ENGINE WON’T TURN OVER
Mower blades engaged- - - - - - - - - - - - - - - - - - - - - - -disengage blades
Drive not in neutral - - - - - - -move control levers to neutral “OUT”
Circuit breaker trips - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - reset
Dead battery- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - charge or replace
Solenoid- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer
Ignition switch- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer
Starter- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer
Parking brake not on- - - - - - - - - - - - - - - - - - - - -engage parking brake
2. ENGINE WILL TURN OVER BUT WON’T START
No fuel- - fuel and/or clean or replace fuel filters/open fuel vavle
3. HARD TO START ENGINE
Fuel line clogged- -clean fuel line/check fuel filter/open fuel vavlve
Faulty fuel pump- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -consult dealer
4. ENGINE STARTS BUT CUTS OUT
Water in fuel- - - - - - - - - - - - - - - -drain old fuel-replace with new fuel
Clogged fuel line- - - - - - - - - - - - - - - - - - - - check fuel filterclean fuel line
Fuel tank vent plugged- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - check vent
Faulty fuel pump- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - consult dealer
Engine dies when control levers moved “IN”-release parking brake
*see engine manual for engine adjustments
TROUBLESHOOTING