Dorcy 41-1086 - Manual

IMPORTANT
SAFETY
INSTRUCTIONS
• Never touch the lens while in
use. Danger of high heat at
the lens surface.
• Light of halogen spotlight is
very bright, so NEVER look
directly into light or shine into
someone’s eye.
• Never touch the halogen
lamp with bare hands (natural
oil from hand could damage
the bulb).
• Never use the spotlight in
water or close to fire.
• NEVER leave the spotlight
unattended during use, and
always KEEP AWAY FROM
CHILDREN.
• ONLY use the accompanied
AC power supply OR the 12V
DC car plug to recharge the
spotlight.
BEFORE USE:
Charge the battery fully before use.
Please read the following instructions carefully
in order to avoid any functional disorders or
damages.
The spotlight can be turned on by pressing
push-button switch.
Turn off the spotlight by releasing the push-
button switch.
For constant light, keep the push-button switch
down, and then push the fastener lock switch
to the right.
To switch off the constant light, move fastener
lock switch back to the left.
The Spotlight contains a 6V6Ah lead acid
battery, which has to be charged before its first
use (Please read the section on recharging).
CHANGING THE BATTERY
Carefully remove the 4 screws from the bottom
battery compartment. Disconnect the battery from
the terminals. Replace with another 6V6Ah lead
acid battery and re-connect the battery terminal
(red color wire to red terminal, black color wire to
black color terminal). Charge the battery fully
before use.
STEPS IN CHANGING THE BULB:
Remove the rubber bezel of the light head, remove
the battery compartment from the bottom, and then
loosen the 6 screws on the side of the body. Open
the container and remove the split pin on the back
of the reflector. Loosen the screw and remove the
lamp wire from the holder. To remove the light
bulb, pull out the flat socket from the spring clip.
Insert a new H3-6V 100W Quartz halogen bulb.
Then repeat the above steps in reverse order to
assemble the spotlight.
STEPS TO RECHARGE THE
BATTERY
Connect the 12V DC car plug adapter OR the
AC power supply into the appropriate socket
on the back of the spotlight; then, plug the AC
power supply into a wall AC outlet or the
12VDC car plug adapter into the car 12VDC
cigarette lighter socket; As soon as the
recharger has been connected, the red LED
light on the spotlight body will light up. The
red LED will go dim when spotlight is fully
charged.
Do not use spotlight while charging.
CHARGING TIME is approximately 20
hours using the AC charger and 12 hours using
the DC charger.
Disconnect from power
source when charge is complete.
If storing for more than 3 months, periodically
recharge battery so battery will not totally
discharge.
Never allow the battery to go
completely dead, this may damage the
battery cells and they may not
regenerate.
MAXIMUM working time when fully
charged: 30 minutes.
REPLACEMENT PARTS:
41-0796 6V 6Ah battery
41-8087 DC Adaptor
41-8086 AC Adaptor 120V 300 mA
41-0081 H3 6V 100 Watt Halogen Bulb
41-1086
2 Million Candle Power
Rechargeable Spotlight
www.dorcy.com
Dorcy International
Columbus, Ohio 43217
06/14/07