R&D Batteries Carbon Zinc Batteries - Manual

Notice: The information and recommendations set forth are made in good faith and are believed to be accurate at
the date of preparation. Panasonic Industrial Company makes no warranty expressed or implied.
Panasonic_CarbonZinc_D_Info.doc Page 1 of 1
Panasonic Batteries
Panasonic Industrial Company
A Division of Matsushita Electric Corporation of America
Two Panasonic Way
Secaucus, NJ 07094
Toll Free:
877-726-2228
Fax: 847-468-5750
e-mail: [email protected]
Internet: www.panasonic.com/batteries
MSDS
Material Safety Data Sheets (MSDS) are a sub-requirement of the Occupational Safety and Health Administration
(OSHA) Hazard Communication Standard, 29 CFR Subpart 1910.1200. This Hazard Communication Standard does
not apply to various subcategories including anything defined by OSHA as an "article". OSHA has defined "article" as a
manufactured item other than a fluid or particle; (i) which is formed to a specific shape or design during manufacture; (ii)
which has end use function(s) dependent in whole or in part upon its shape or design during end use; and (iii) which
under normal conditions of use does not release more than very small quantities, e.g. minute or trace amounts of a
hazardous chemical, and does not pose a physical hazard or health risk to employees.
Because all of our batteries are defined as "articles", they are exempt from the requirements of the Hazard
Communication Standard, hence a MSDS is not required.
The following components are found in a Panasonic Carbon Zinc battery:
Component Material Formula
Positive Electrode Manganese Dioxide MnO
2
Negative Electrode Zinc Zn
Electrolyte Ammonium Chloride NH
4
Cl
2
Zinc Chloride ZnCl
2
Disposal
Since January 1992 all Panasonic Carbon Zinc batteries are manufactured with "no mercury added ". These
batteries are classified by the federal government as a non-hazardous waste and are safe for disposal in the
normal municipal waste stream.
Transportation
Panasonic Carbon Zinc batteries are considered to be “dry cell” batteries and are unregulated for purposes of
transportation by the U.S. Department of Transportation (DOT), International Civil Aviation Administration (ICAO),
International Air Transport Association (IATA) and the International Maritime Organization (IMO). The only
requirements for shipping these batteries by DOT is Special Provision 130 which states: "Batteries, dry are not subject
to the requirements of this subchapter only when they are offered for transportation in a manner that prevents the
dangerous evolution of heat (for example, by the effective insulation of exposed terminals). The only requirements for
shipping these batteries by ICAO and IATA is Special Provision A123 which states: “An electrical battery or battery
powered device having the potential of dangerous evolutions of heat that is not prepared so as to prevent a short-circuit
(e.g. in the case of batteries, by the effective insulation of exposed terminals; or in the case of equipment, by
disconnection of the battery and protection of exposed terminals) is forbidden from transportation.”
Product Information Sheet
Product: Carbon Zinc Batteries
Applicable models/sizes:
All
Revision:
D; Dated 10/01/04
The batteries referenced herein are exempt articles and are not subject to the OSHA Hazard
Communication Standard requirement. This sheet is provided as a service to our customers.