JLG 740AJ Parts Manual - Manual (Page 101)

3121146 4-7
SECTION 4 PLATFORM
S
E
C
T
I
O
N
4
P
L
A
T
F
O
R
M
FIGURE 4-2. PLATFORM CONSOLE ASSEMBLY
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.
0861237 CONSOLE BOX INSTALLATIONS Ref 5/D
1 0860984 Box, Console 1
2 4340678 Support, Hand 1
3 3538819 Plate, Mounting 1
4 1600284 Controller Assembly (Swing & Lift) (See CONTROL-
LER ASSEMBLY (SWING & LIFT) for Breakdown) 1
5 1600283 Controller Assembly (Drive & Steer) (See CONTROL-
LER ASSEMBLY (DRIVE & STEER) for Breakdown) 1
6 4340684 Support, Hand 1
7 1702676 Decal (Horn/Drive Speed/Level) 1
8 1702564 Decal (Stop) 1
9 1702565 Decal (Drive and Steer) 1
10 1702566 Decal (Lift and Swing) 1
11 1702567 Decal (Speed/Lower Lift/Tele/Rotate/Jib) 1
12 2760105 Housing, Display Light 1
13 4360387 Switch, Pushbutton 1
14 2560136 Knob, Speed Control 1
15 4360407 Controller, Speed 1
16 3910610 Screw #6-32NC x 5/8” 16
17 4360475 Switch, Emergency Stop 1
17A 7020175 Cap, Mushroom Head 1
17B 7020176 Block, Contact 1
18 4360476 Switch, Contact Block 1
19 4360314 Switch, Toggle 6
20 4360331 Switch, Toggle 1
21 0140026 Alarm 1
22 3790012 O-Ring 7
23 3520028 Plug, Hole (For switch call-outs at these locations, refer
to options installation below) 4
24 1600218 Card, Control 4
25 0641610 Bolt 3/8”-16NC x 3/4” 4
26 4751600 Flatwasher 3/8” 4
27 4460467 Tool, Pin Extraction (Blue 16-18 Gauge) (Not Shown) 1
28 4460510 Tool, Pin Extraction (Yellow 12-14 Gauge) (Not Shown) 1
29 0641408 Bolt 1/4”-20NC x 1” 3
30 3311405 Locknut 1/4”-20NC 3
31 4740362 Washer 1/4” (Fender) 3
32 4460071 Connector, Strain Relief 1
33 0641404 Bolt 1/4”-20NC x 1/2” 8
34 3311401 Nut 1/4”-20NC 1
35 1320060 Clamp 1
36 1320095 Clamp 1
37 3740058 Relay - 4PDT 3
38 3740063 Spring, Relay 3
39 4360232 Breaker, Circuit - 15 Amp 2
40 0641406 Bolt 1/4”-20NC x 3/4” 3
41 1703090 Decal - Control Card (Lift) 1