JLG 450AJ ANSI Parts Manual - Manual (Page 79)

3120750 2-31
SECTION 2 TURNTABLE
S
E
C
T
I
O
N
2
T
U
R
N
T
A
B
L
E
ENGINE COMPONENTS Ref.
2000156 Prior to S/N 39831
2000160 S/N 39831 to S/N 46089
301 Use 7019988 Carburetor (was p/n 7019974) 1
7019933 Kit, Carburetor Repair 1
7027292 Float Assembly 1
70000163 Needle, Spring Loaded (Fuel Valve) 1
7025122 Base, Carburetor 1
7016605 Choke, Automatic 1
Use 7000646 Gasket, Carburetor (Bottom) (was p/n 7019975) 1
7024321 Gasket, Carburetor (Top) 1
302 7012679 Starter (Not Shown) 1
303 7019977 Alternator 1
7019997 Regulator 1
304 Use 7027402 Belt, Drive (was p/n 7019979) 1
7019978 Tensioner, Belt 1
305 Use 7023687 Module, Ignition (was p/n 7019961) 1
306 7019980 Harness, Engine Wiring (Not Shown) 1
307 Water Pump Assembly Options: 1
Not Available Engine 2000156
7022153 Engine 2000160
7019985 Pulley, Water Pump 1
7022156 Thermostat, Assembly 1
7019982 Inlet Tube, Water Pump 1
7025134 Gasket, Water Outlet Connection (Not Shown) 1
308 Fuel Pump Assembly Options: 1
7016600 Engine 2000156 (Facet)
7019983 Engine 2000160 (Airtex)
309 7016601 Strainer, Fuel 1
310 7021869 Filter, Oil (was p/n 7014501) 1
311 7019976 Flywheel (Not Shown) 1
7022180 Ring Gear (Not Shown) 1
311A Use 1660250 Coupling, Pump (15 Tooth) (was p/n 7016662) 1
312 70002307 Gasket (Exhaust Manifold to Pipe) 1
313 7022143 Gasket (Exhaust Manifold to Head) (Not Shown) 1
7019924 Gasket (Exhaust Manifold - Turbo) (Not Shown) 1
Use 7025126 Gasket (Intake Manifold) (was p/n 7019923) (Not Shown) 1
7025125 Gasket, Intake (Manifold to Cylinder Head) (Not Shown) 1
314 7019981 Indicator, Oil Level 1
315 Switch, Oil Sender Options: 1
Not Available Engine 2000156
7023637 Engine 2000160
316 Spark Plug Options (Not Shown): 4
Not Available Engine 2000156
7019932 Engine 2000160
7019930 Coil, Ignition (Not Shown) 1
FIGURE 2-8. FORD ENGINE INSTALLATION (WITH CARBURETOR) (PRIOR TO S/N 46089)
(CONTINUED)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.