JLG 1100SB Parts Manual User Manual
Page 129
2-97
SECTION 2 TURNTABLE
FIGURE 2-21. 7500W SKYPOWER GENERATOR INSTALLATION
ITEM #
PART NUMBER
QTY.
DESCRIPTION
REV.
Ref
7500W SKYPOWER GENERATOR INSTALLATION
1001125427
Ref
60Hz Spec (TD2011 Engines)
A
1001137590
Ref
60Hz Spec (TCD2.9L4 Engines)
C
Ref
Note: SkyPower Generator is Standard On ANSI Specs.
Ref
Note: See ELECTRICAL SECTION for Boom Cable
Installation.
1
0100011
AR
Compound, Locking
2
0100019
AR
Compound, Locking
3
0100048
AR
Grease, Dielectric
4
1
Belt, Generator Options:
0480128
TD2011 Engine
1001142645
TCD2.9L4 Engines
5
0641404
5
Bolt 1/4in-20NC x 1/2in
6
0641508
4
Bolt 5/16in-18NC x 1in
7
0641516
3
Bolt, 5/16in-18NC x 2in
8
0641810
4
Bolt, 1/2in-13NC x 1-1/4in
9
0860038
2
Box, Switch-Weatherhead
10
0861538
1
Box, Generator Control
7024488
1
Card, Circuit - Generator Power
See Note
1
Fuse (Note: Not Available - Purchase Locally)
7024489
1
Card, Circuit - Control
Ref
Note: Same Circuit Card (P/N 7024489) is used for both
60Hz & 50Hz. When replacing card, rocker switch on card
must be set for required application.
70000619
1
Harness, Circuit Card
11
1
Junction Box Assembly Options (See Items 101-128 for
Breakdown):
0861542
1
60Hz Spec (TD2011 Engines)
1001142914
60Hz Spec (TCD2.9L4 Engines)
12
0902888
1
Bracket, Generator Junction Box
13
0962520
1
Bushing, Taper
14
1
Generator, 7500W Options:
2460048
Deutz TD2011 Engines
1001136988
Deutz TCD2.9L4 Engines
Use
70003631
1
Brushholder Assembly (Not Shown) (was p/n 7024484)
7024485
1
Breaker, Circuit 30Amp (Not Shown)
70001696
1
Boot, Breaker (was p/n 7024486) (Not Shown)
70001966
1
Bearing, Ball Radial (Located in Belt Tensioner Endbell -
Not Shown)
7027799
1
Block, Connector 6 Position (Not Shown)
70002460
1
Nut, Brass (Attaches p/n 7027799 to Cover) (Not Shown)
70002297
AR
Stud 1/4in-20NC x 12-7/8in (Not Shown)
7026188
1
Clamp, Cable (Not Shown)
7026597
1
Connector with Leads (Not Shown)
7026626
1
Connector with Pins (Not Shown)
70001100
1
Rotor/Armature (Not Shown)
70001384
1
Bearing, Ball Radial (Not Shown)
70002088
1
Stator (Not Shown)
Use
70004169
1
Plate, End Panel (Not Shown) (was p/n 70002255)