Grilling/searing – Brinkmann Dual Zone Charcoal Grill User Manual

Page 16

Step 1

Lightly coat all interior surfaces of the Professional Dual Zone Grill
including cooking grills with vegetable oil or vegetable oil spray. Do not
coat charcoal grates or charcoal ash tray.

Step 2

Follow the instructions below carefully to build a fire. You may use
charcoal and/or wood as fuel in the Professional Dual Zone Grill (see
“Adding Charcoal/Wood During Cooking” section of this manual).

If using a Charcoal Chimney Starter, follow all manufacturer’s warnings
and instructions regarding the use of their product. Start with 8 to 10
pounds (3.6 to 4.5 kg) of charcoal. When charcoal is burning strong,
carefully place hot coals in center of each charcoal grate.

WARNING:

DO NOT use grill without charcoal ash tray in place. DO NOT
attempt to remove charcoal ash tray while tray contains hot
coals.

Note:

To extend the life of your grill, make sure that hot coals and
wood do not touch the walls of grill.

IF USING CHARCOAL CHIMNEY STARTER, PROCEED TO STEP 5

If you choose to use charcoal lighting fluid, ONLY use charcoal lighting
fluid approved for lighting charcoal. Do not use gasoline, kerosene,
alcohol or other flammable material for lighting charcoal. Follow all
manufacturer’s warnings and instructions regarding the use of their
product. Start with 8 to 10 pounds (3.6 to 4.5 kg) of charcoal. Place
the charcoal in center of each charcoal grate.

Step 3

Saturate charcoal with lighting fluid. With lid and doors open wait 2 to
3 minutes to allow lighting fluid to soak into charcoal. Store charcoal
lighting fluid safely away from the grill.

Step 4

With grill lid and doors open, stand back and carefully light charcoal
and allow to burn until covered with a light ash (approximately 20
minutes).

WARNING:

Charcoal lighting fluid must be allowed to completely burn off
prior to closing grill lid and doors (approximately 20
minutes). Failure to do this could trap fumes from charcoal
lighting fluid in grill and may result in a flash-fire or explosion
when lid is opened.

Step 5

Place cooking grills on grill support lips. Use charcoal grate adjuster
cranks to position charcoal grates to desired cooking level.

High Charcoal Grates Level

(Searing)

Middle Charcoal Grates Level

(Grilling)

Low Charcoal Grates Level

(Grilling)

Grilling/Searing

Charcoal Grates

INS_810-3246-0_BI.qxd 12/28/07 3:24 PM Page 14