Karcher KM 120-150 R Bp Pack - Manual (Page 5)

English 5
Please read and comply with
these instructions prior to the
initial operation of your appliance. Retain
these operating instructions for future refer-
ence or for subsequent possessors.
– 6.654-143.0: The charger is only suited
to charge PzS lead batteries with a
nominal voltage of 24 V and a nominal
capacity of 240 Ah.
– 6.654-188.0: The charger is only suited
to charge PzS lead batteries with a
nominal voltage of 24 V and a nominal
capacity of 400 Ah.
– Do not use the charger outdoors, on
streets or explosion hazardous rooms.
– Warning and information plates on the
machine provide important directions
for safe operation.
– Apart from the notes contained herein
the general safety provisions and rules
for the prevention of accidents of the
legislator must be observed.
– Keep children away from batteries and
charger.
– The charger may not be modified.
– The charger may only be repaired by
trained personnel.
– The proper discharge of the exhaust
gases must be ensured.
– All burning, glowing or spark distributing
materials are prohibited in the vicinity of
the charger.
– Wear safety clothes and protective gog-
gles.
– Do not touch your face or eyes while
working with batteries; danger of chem-
ical burns.
ƽ Danger
Risk of explosion!
If unsuitable batteries are used, the battery
can emit gas, boil and explode.
ƽ Danger
The battery charging process can give rise
to explosive gases.
ƽ Danger
Risk of fire and explosion!
– Smoking and naked flames are strictly
prohibited.
– Rooms where batteries are charged
must have good ventilation because
highly explosive gas is emitted during
charging.
ƽ Danger
Danger of causticization!
– Rinse thoroughly with lots of clear water
if acid gets into the eye or comes in con-
tact with the skin.
– Then consult a doctor immediately.
– Wash off the acid If it comes in contact
with the clothes.
Your sales outlet should be informed about
any transit damage noted when unpacking
the product.
– The type of charger can be read on the
type plate on the appliance.
– The entire charging process is control-
led and regulated electronically.
– The charge control increases the bat-
tery life.
ƽ Danger
Moisture will damage the battery charger
and can cause electric shock.
– The charging location must be dry, free
of dust and well-ventilated.
– In order to ensure sufficient cooling,
there must be an open space 10 cm
around the charger with a cover.
– All open air louvres of the charger must
be freely accessible.
– Do not place objects on top of the
charger cover.
– The charger must be protected from
electricity conducting dusts (e.g. soot,
metal shavings...).
Î Open the hood of the sweeper and se-
cure it using the hood support.
Note
Always keep the hood open during the
charging process.
Î
Connect the charger to the mains.
– Follow the operating instructions of the
sweeper during charging.
– Do not separate the charger cables
from the battery.
ƽ
Danger
Never connect or disconnect the charger
cable while the charger is turned on. Other-
wise, the charger can be damaged or there
might be sparks on the charger cable.
Î Pull the mains plug from the mains
socket and place it in its holder.
Î Check the voltage source
Î Check the fuse.
Î Inform the KÄRCHER customer serv-
ice.
In order to safeguard warranty claims, all
service and maintenance work during the
warranty period must be carried out by the
authorised KÄRCHER specialist in accord-
ance with the maintenance booklet.
Environmental protection
The packaging material can be
recycled. Please do not throw
the packaging material into
household waste; please send it
for recycling.
Old appliances contain valuable
materials that can be recycled;
these should be sent for recy-
cling.. Batteries and accumula-
tors contain substances that
must not enter the environment.
Please dispose off old devices,
batteries and rechargeable bat-
teries through suitable waste
collection systems.
Proper use
Safety instructions
Pb General information
Before Startup
Battery charging room/installation
point
Start up
Operation
Battery load indicator
orange Battery is being
charged
green Battery is charged
red Battery is not connect-
ed, deep discharged or
defective.
blinks red Battery defective
Shutting down
Troubleshooting
Charger is not responding
Warranty