Ag Spray Equipment AG25LG5FHGD-GR - Manual

Warranty/Parts/Service
Products are warranted for one year from date of purchase
against manufacturer or workmanship defects.
Commercial users have a 90 day warranty.
Your authorized dealer is the best source of replacement parts
and service. To obtain prompt, efficient service, always
remember to give the following information...
- Correct Part Description and/or part number.
- Model number/Serial number of your sprayer.
Part descriptions and part numbers can be obtained from the
illustrated parts list section(s) of this manual.
Whenever you need parts or repair service, contact your
distributor/dealer first. For warranty work, always take your
original sales slip, or other evidence of purchase date, to your
distributor/dealer.
25 Gal. Corrosion-Resistant Polyethylene Tank •
12 Volt Diaphragm Pump, 1.8 g.p.m. - 60 p.s.i. •
Aluminum Pistol-Grip Handgun (43LA-AL6) •
15 Ft. Handgun Hose •
5-Nozzle Boom with 100" Spray Coverage •
Bypass Line (for Pressure Control) / Pressure Gauge •
4.10/3.50 x 6" Pneumatic Tires •
Technical Specifications
Assembly
Your sprayer has been mostly assembled at the factory.
A couple of requirements will be for you to hook up your
battery leads to a fully charged 12 Volt battery. The red
wire must be connected to the "hot" lead, and the black
wire should be connected to the ground.
Bolt the tongue to the frame with the hardware provided.
(see exploded view)
Affix the tires over the axles (valve stem out) and secure
in place with the provided washer/cotter pins.
Remove the drain plug assembly and handgun clips from
the parts bag and place them onto the tank as shown in
the exploded view drawing.
Remove the pressure gauge from the parts bag and
thread it into the gauge "TEE" on the pressure side of the
pump. Use a good grade of thread sealant, to insure no
leaks.
Attach the boom brackets to the frame, then attach the
boom to the boom brackets. Use the hardware shown.
Route the boom feeder hose back to the boom, attaching it
to the "TEE" fitting on the boom. Secure in place with a
hose clamp.
CAUTION: Always check the vehicle load rating
before using this sprayer. Do not exceed the
recommended rating.

(25 Gallon Lawn & Garden Trailer Sprayer - GREEN Frame)
Owner's Manual
General Information
Thank you for purchasing this Ag Spray product. The purpose
of this manual is to assist you in operating and maintaining
your lawn & garden spot sprayer. Please read it carefully, as it
furnishes information which will help you achieve years of
trouble-free operation.
Form No. 1964 [5008276 (01/10)] Printed in the U.S.A.
www.agspray.com
1100 New Industry Lane
Hopkinsville, KY 42240
P: 800-637-7172
F: 270-885-7392
1563 S. Oates Street
Dothan, AL 36301
P: 800-227-4098
F: 334-673-1974
104 Eastman Street
Greenwood, MS 38930
P: 800-844-4524
F: 662-455-4442