Associated Equipment 6003 - Manual (Page 4)

4
NOTES ON RECOVERY OF DEEPLY DISCHARGED BATTERIES:
a.
Not all deeply discharged batteries can be recovered.
b. Most weak batteries will be detected while charging. However, some batteries which have been recovered from a deep discharge will
maintain an acceptable open circuit voltage but have a reduced capacity under load. Always load test or otherwise test a recovered battery
to determine if the CCA capacity is within 80% of the rated value.
c. Some large deeply discharged batteries may be recovered, but are not recharged enough in the 70 minute maximum charge time to be put
back into service. Either put it on a suitable finish charger, such as AEC Model 9410 or 9420, or allow battery to cool and charge again on
this charger.
WIRING DIAGRAM
M ODEL
6003 REPAIR PARTS
Item Description Part No.
1 Front Leg . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 605183
2 Axle w/nuts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 610052
3 Wheel w/nuts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 610849
4 Rectifier w/wiring harness . . . . . . . . . . . . . . . . . . . . 610948
5 Transformer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 610949
6 Fan Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 610189
7 Fan Motor w/blade . . . . . . . . . . . . . . . . . . . . . . . . . . 610190
8 AC Circuit Breaker . . . . . . . . . . . . . . . . . . . . . . . . . . 610920
9 DC Circuit Breaker . . . . . . . . . . . . . . . . . . . . . . . . . . 610536
10 Switch (Flooded/Seal or On/Off), qty. 1 . . . . . . . . . . 610918
11 Switch (Manual Start), qty. 1 . . . . . . . . . . . . . . . . . . 610954
12 AC Cord . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 610951
13 Side Terminal Adapter (qty. 1) . . . . . . . . . . . . . . . . . 610181
14 DC Cable Positive . . . . . . . . . . . . . . . . . . . . . . . . . . 610952
15 DC Cable Negative . . . . . . . . . . . . . . . . . . . . . . . . . 610953
16 Clamps (1 pair w/jaws) . . . . . . . . . . . . . . . . . . . . . . . . . 6202
17 Jaw Kit (repairs 1 clamp) . . . . . . . . . . . . . . . . . . . . . . . 6204
18 PCB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 610950
MAINTENANCE INSTRUCTIONS
Worn clamps should be replaced. Worn parts can lead to poor connections and present a safety hazard. See parts list for part number of D.C.
Cord kit. Any Maintenance or repair of this unit that involves disassembly of the cabinet should be done only by a qualified serviceman.
Incorrect reassembly may result in a risk of electric shock when the unit is subsequently used.