Lincoln Electric METALUX 248HO User Manual
Can-cw715, For welding consumables and related products, Continued on side two)

Date:
1/11/2008
MSDS No.:
CAN-CW715
Trade Name:
UltraCore 712A80
Sizes:
All
Supersedes:
2/11/05
M A T E R I A L S A F E T Y D A T A S H E E T
For Welding Consumables and Related Products
Conforms to Workplace Hazardous Materials Information System (WHMIS) Rev. November, 1988
Section I & II - Preparation and Product Information
Product Type:
Flux Cored Electrode
Representative Classifications:
AWS E71T-1MJH8
E71T-9MJH8
E71T-12MJH8
The Lincoln Electric Company of Canada LP
179 Wicksteed Avenue
Toronto, Ontario M4G 2B9 CANADA
Phone: (416) 421-2600
Prepared by The Lincoln Electric Company, Cleveland, Ohio, USA
(216) 481-8100, on the date shown above.
Section III - Hazardous Ingredients (1)
I M P O R T A N T !
This section covers the materials from which this product is manufactured. The fumes and gases produced during welding with the normal use of this product
are covered by Section VII; see it for industrial hygiene information.
CAS Number shown is representative for the ingredients listed. All ingredients listed may not be present in all sizes.
(1)
The term “hazardous” in “Hazardous Ingredients” should be interpreted as a term required and defined in the Hazardous Products Act and does
not necessarily imply the existence of any hazard.
Ingredients:
CAS No. Wt. %
TLV
mg/m
3
LD
50
(Route/Species)
LC
50
mg/m
3
(Route/Species)
Titanium dioxides
13463-67-7
5-10
10
Not Available
Not Available
Iron 7439-89-6
1-5
10*
Not Available
Not Available
Manganese and/or manganese alloys and compounds (as Mn)
7439-96-5
1-5
0.2
9 g/kg
(oral/rat)
2.3 LCLo
(inhalation/human)
Magnesium and/or magnesium alloys and compounds (as Mg)
7439-95-4
0.1-1
10*
230 mg/kg LDLo
(oral/dog)
Not Available
Silicon and/or silicon alloys and compounds (as Si)
7440-21-3
0.1-1
10*
Not Available
Not Available
Mineral silicates
1332-58-7
0.1-1
5**
590 g/kg LDLo
(oral/rat) reproductive
Not Available
Nickel (metal)
7440-02-0
0.1-1
1.5
50 mg/kg LDLo
(intravenous/mouse)
Not Available
Fluorides (as F)
7789-75-5
0.1-1
2.5
4250 mg/kg
(oral/rat)
Not Available
Boron alloys (as B)
11108-67-1
0.1-1
10*
2.0 g/kg
(oral/mouse)
Not Available
Carbon steel tube
7439-89-6
60-100
10*
Not Available
Not Available
Notes:
(*) Not listed. Nuisance value maximum is 10 milligrams per cubic
meter. TLV value for iron oxide is 5 milligrams per cubic meter.
(**
)
As respirable dust.
(LDLo, LCLo) Lowest published toxic concentration.
Section IV - Physical Data
Physical data such as odor, vapor pressure, density, evaporation rate and freezing or boiling points are not listed as they are not applicable to
this product and its use.
Section V - Hazard Data
Non Flammable; Welding arc and sparks can ignite combustibles and flammable products. See CSA W117.2 Section 9.7 as referenced in
Section VIII. Product is inert, no special handling or spill procedures required.
Rev 9/07
(CONTINUED ON SIDE TWO)