Kohler Command CV740 - Manual (Page 6)

6
Figure 5. Engine Identification Label.
EPA
CARB
Category C
250 hours
Moderate
125 hours
Category B
500 hours Category A
1000 hours
Intermediate
250 hours Extended
500* hours
Engine Identification Numbers
When ordering parts, or in any communication involving
an engine, always give the Model, Specification, and Serial
Numbers of the engine.
The engine identification numbers appear on a decal (or
decals) affixed to the engine shrouding. Include letter
suffixes, if there are any. Record your engine identification
numbers on the identification label below (Figure 5) for
future reference.
*Extended hours for Model CV750 is 1000.
Refer to certification label for engine displacement.
Exhaust Emission Control System for models CV18/
CV620, CV20/CV640, CV23/CV680, CV675, CV730,
CV740, CV750 is EM. Exhaust Emission Control
System for models CV26/CV735 and CV745 are EM,
O2S, ECM, MFI.
Model Designation
Model CV20S for example: C designates Command
engine, V designates vertical crankshaft, and 20
designates horsepower. Some model numbers (CV675)
use a numerical designation rather than horsepower.
A letter suffix designates a specific version as follows:
Suffix Designates
S Electric Start
ST Electric/Retractable Start
Operating Instructions
Also read the operating instructions of the equipment this
engine powers.
Pre-Start Checklist
• Check oil level. Add oil if low. Do not overfill.
• Check fuel level. Add fuel if low.
• Check cooling air intake areas and external
surfaces of engine. Make sure they are clean and
unobstructed.
• Check that the air cleaner components and all
shrouds, equipment covers, and guards are in
place and securely fastened.
• Check that any clutches or transmissions are
disengaged or placed in neutral. This is especially
important on equipment with hydrostatic drive.
The shift lever must be exactly in neutral to
prevent resistance which could keep the engine
from starting.
The Emission Compliance Period referred to on the
Emission Control or Air Index label indicates the
number of operating hours for which the engine has
been shown to meet Federal and CARB emission
requirements. The following table provides the Engine
Compliance Period (in hours) associated with the
category descriptor found on the certification label.
Emission Compliance Period (Hours)
For Models CV18-CV745
IMPORTANT ENGINE INFORMATION
THIS ENGINE MEETS EMISSION REGS FOR U.S. EPA 2005 AND
LATER AND EC STAGE II (SN:4) SI SMALL OFF-ROAD ENGINES
AND CA 2005 AND LATER LSI ENGINES
EMISSION COMPLIANCE PERIOD:
EPA:
CERTIFIED ON:
REFER TO OWNER'S MANUAL FOR HP RATING,
SAFETY, MAINTENANCE AND ADJUSTMENTS
FAMILY
TYPE APP
DISPL (CC)
MODEL NO.
SPEC. NO.
SERIAL NO.
BUILD DATE
OEM PROD. NO.
For Model CV750
KOHLER CO. KOHLER, WISCONSIN USA
1-800-544-2444 KohlerEngines.com
N11236
IMPORTANT ENGINE INFORMATION
THIS ENGINE MEETS U.S. EPA PH2 AND EC STAGE II (SN:4)
EMISSION REGS FOR SI SORE NOT FOR SALE IN CALIFORNIA
UNLESS PREEMPT PER SEC. 209(e)(1) of CAA
KOHLER CO. KOHLER, WISCONSIN USA
EMISSION COMPLIANCE PERIOD:
EPA:
CERTIFIED ON:
REFER TO OWNER'S MANUAL FOR HP RATING, SAFETY,
MAINTENANCE AND ADJUSTMENTS
FAMILY
TYPE APP
DISPL (CC)
MODEL NO.
SPEC. NO.
SERIAL NO.
BUILD DATE
OEM PROD. NO.
N11236
1-800-544-2444 KohlerEngines.com
IMPORTANT ENGINE INFORMATION
THIS ENGINE MEETS U.S. EPA PH2, EC STAGE II (SN:4) AND CA
2008 AND LATER EXH EMISSION REGS FOR SI SORE
EMISSION COMPLIANCE PERIOD:
EPA:
CARB:
CERTIFIED ON:
REFER TO OWNER'S MANUAL FOR HP RATING, SAFETY,
MAINTENANCE AND ADJUSTMENTS
FAMILY
TYPE APP
DISPL (CC)
MODEL NO.
SPEC. NO.
SERIAL NO.
BUILD DATE
OEM PROD. NO.
N11236
1-800-544-2444 KohlerEngines.com
KOHLER CO. KOHLER, WISCONSIN USA