Generac 004451 - Manual (Page 5)

3
Ꮨ ELECTRICAL HAZARDSᏘ
• All generators covered by this manual produce dangerous
electrical voltages and can cause fatal electrical shock. Utility
power delivers extremely high and dangerous voltages as
does the generator when it is in operation. Avoid contact with
bare
wires, terminals, connections, etc., while the unit is
running. Ensure all appropriate covers, guards and barriers
are in place before operating the generator. If you must work
around an operating unit, stand on an insulated, dry surface
to reduce shock hazard.
• Do not handle any kind of electrical device while standing in water,
while barefoot, or while hands or feet are wet. DANGEROUS
ELECTRICAL SHOCK MAY RESULT.
• The National Electrical Code (NEC) requires the frame and external
electrically conductive parts of the generator to be connected to an
approved earth ground. Local electrical codes also may require
proper grounding of the generator electrical system.
• In case of accident caused by electric shock, immediately shut down
the source of electrical power. If this is not possible, attempt to free
the victim from the live conductor. AVOID DIRECT CONTACT
WITH THE VICTIM. Use a non-conducting implement, such as
a rope or board, to free the victim from the live conductor. If the victim
is unconscious, apply first aid and get immediate medical help.
• Never wear jewelry when working on this equipment. Jewelry can
conduct electricity resulting in electric shock, or may get caught in
moving components causing injury.
Ƹ FIRE HAZARDS Ƹ
• For fire safety, the generator must be operated and maintained
properly. Operation always must comply with applicable codes,
standards, laws and regulations. Adhere strictly to local, state and
national electrical and building codes. Comply with regulations the
Occupational Safety and Health Administration (OSHA) has
established. Also, ensure that the generator is operated in
accordance with the manufacturer’s instructions and
recommendations. Do not alter the construction of generator or
change controls which might create an unsafe operating condition.
• Keep a fire extinguisher near the generator at all times.
Extinguishers rated “ABC” by the National Fire Protection
Association are appropriate for use on the standby electric system.
Keep the extinguisher properly charged and be familiar with its use.
If you have any question pertaining to fire extinguishers, consult your
local fire department.
Ʒ EXPLOSION HAZARDS Ʒ
• Do not smoke around the generator. Wipe up any fuel or oil
spills immediately. Ensure that no combustible materials are
left on or near the generator, as FIRE or EXPLOSION may
result. Keep the area surrounding the generator clean and
free from debris.
• Gasoline is extremely EXPLOSIVE.
STANDARDS INDEX
In the absence of pertinent standards, codes, regulations and laws, the
published information listed below may be used as a guideline for
operation of this equipment.
1. NFPA No. 70, NFPA HANDBOOK OF NATIONAL ELECTRIC
CODE.
2. Article X, NATIONAL BUILDING CODE, available from the American
Insurance Association, 85 John Street, New York, N.Y. 10038.
3. AGRICULTURAL WIRING HANDBOOK, available from the Food
and Energy Council, 909 University Avenue, Columbia, MO 65201.
4. ASAE EP-3634, INSTALLATION AND MAINTENANCE OF FARM
STANDBY ELECTRICAL SYSTEMS, available from the American
Society of Agricultural Engineers, 2950 Niles Road, St. Joseph, MI
49085.
5. NFPA No. 30, FLAMMABLE AND COMBUSTIBLE LIQUIDS CODE.
IMPORTANT SAFETY INSTRUCTIONS
Commercial-Industrial-Residential Portable Generator System