Honeywell HW7500EL - Manual (Page 42)

NORTHSHORE POWER SYSTEMS EMISSIONS CONTROL WARRANTY
36 www.honeywellgenerators.com HW7500E/HW7500EL Portable Electrical Generator Owner’s Manual
NORTHSHORE POWER SYSTEMS
EMISSIONS CONTROL WARRANTY
Honeywell Portable Generator
WARRANTY STATEMENT
The U.S. Environmental Protection Agency (EPA) and Califor-
nia Air Resources Board (CARB) require manufacturers of
small off-road engines (SORE) to warranty their products with
a 2-year warranty for those components that are specified as
being part of the emission control system. Northshore Power
Systems, LLC (NSP), CARB, and EPA offer the following
explanation of the Emission Control Warranty.
In the United States and California, new small off-road
engines must be designed, built, and equipped to meet strin-
gent anti-smog standards. NSP must warrant the emission
control system on your small off-road engine for the periods
of time listed below provided there has been no abuse,
neglect or improper maintenance of your small off-road
engine. The emissions warranty is a defects warranty and is
not related to an in-use emissions test.
Your emission control system may include parts such as the
carburetor or fuel injection system, the ignition system, and
the catalytic converter. Also included may be hoses, belts,
connectors and other emission-related assemblies.
Where a warrantable condition exists, NSP will repair your
small off-road engine at no cost to you, including diagnosis,
parts, and labor.
COVERAGE
Emissions control parts on the engine are warranted for a
period of two years, subject to provisions set below. If any
covered part on your engine is defective, the part will be
repaired or replaced by NSP.
OWNER’S RESPONSIBILITIES
You are responsible to maintain the engine as defined in your
Honeywell Generator Owner's Manual. NSP recommends
that you retain all records/receipts covering maintenance on
your engine, but NSP cannot deny warranty claims based on
the lack of receipts or for your failure to perform all scheduled
maintenance. You may be denied warranty coverage if a part
has failed due to abuse, neglect, improper maintenance or
unapproved modifications.
You are responsible to bring your portable generator to an
authorized NSP Honeywell generator dealer for repairs as
soon as a problem exists. Do not return your generator to
place of purchase for service. For emissions warranty ser-
vice, contact your nearest dealer; a listing is available at
www.honeywellgenerators.com or by calling 1-888-
HWHELP1 (494-3571).
EMISSIONS CONTROL SYSTEMS PARTS
Coverage under this warranty extends only to the emissions
control parts listed below.
1. Fuel Metering System
A. Carburetor gaskets
B. Choke system
C. Clamps
D. Fuel filter (if equipped) and screen
E. Fuel line, control valve, and fittings
F. Fuel pump (if equipped)
G. Gasoline carburetor and internal components
(if equipped)
2. Air Induction System
A. Air cleaner
B. Intake manifold
C. Vent lines
3. Ignition System
A. Ignition coil
B. Spark plug
4. Exhaust System
A. Catalytic converter (if equipped)
B. Exhaust manifold
C. Muffler gasket
5. Crankcase Breather Assembly
A. Breather connection tube
6. Air Injection System
A. Pulse valve
7. Fuel Tank Evaporative Emissions Control System
A. Carbon canister and mounting brackets
B. Fuel cap
C. Fuel tank
D. Purge valves
8. Miscellaneous Items used in above systems
A. Hoses, belts, connectors, valves, and assemblies
B. Switches
WARRANTY PROVISIONS
1. Claims. Warranty claims shall be filed in accordance
with provisions of the NSP warranty and policies estab-
lished with the authorized dealer network.
2. Exclusions. Warranty coverage shall be denied for fail-
ure of an emissions control part caused by abuse,
neglect, improper maintenance as described in the Hon-
eywell Generator Owner's Manual, use of add-on parts,
modified parts, or parts that are not equivalent to original
Honeywell generator parts in performance and durability.
3. Length of Coverage. NSP warrants to the original retail
purchaser and each subsequent owner that the emis-
sions control part shall be free from defects in materials
and workmanship for a period of two years from the date
the generator is delivered to the original retail customer.
4. Repair or Replacement Cost. Repair or Replacement
Cost. Repair or replacement of any emissions control
part will be performed at no charge to the owner, includ-
ing diagnostic labor which leads to the determination that
an emissions control part is defective, if the diagnostic
work is performed at an authorized NSP Honeywell gen-
erator dealer.
5. Consequential Coverage. Coverage noted hereunder
will extend to the failure of any engine components
caused by the failure of any emissions control part still
under warranty.
6. Maintenance. The emissions control parts are war-
ranted only for defects during the warranty period. The