John Deere 6300 - Manual (Page 2)

_.
-
---
.JD350 WITH 6300 BULLDOZER-SPECIFICATIONS
Track shoes (types and sizes)... Grouser, 12- or 14-inch. Open-
center grouser, 12- or 14-in. Triple semi-grouser, open-center,
12-in. Snow shoes, 12- or 14-in. Rubber, 10-in.
Trackpindiameter 1-3/16in.
Track-pin bushing diameter .1-3/4 in.
Number of tracks shoes, each side .36
Total ground contact area (sq. in.):
10-in. shoes .1,350
12-in. shoes ,... .1,628
14-in. shoes .1,904
Ground pressure, 12-in. shoes (lb. per sq. in.) ... . .5.6
Length of track on ground ...69-1/4 in.
Trackgauge 48in.
Adjustment . . . . Hydraulic
Horsepower* (at 2,500 engine rpm):
Grossengineflywheel..........................
Net engine flywheel.
Engine equipped with fan,
air cleaner, water pump, lubricating oil pump,
fuel pump, and alternator 42 42
Drawbar 30 30
Travel Speeds and Drawbar Pull* (with adequate weight anrl
traction)
Gasoline Diesel
46 46
Drawbar lb.
Pull at
maximum torque
9,000
7,200
4,200
1,800
Drawbar lb.
Pull at 2,500
engine rpm
7,500
6,000
3,500
1,500
Travel Speed
Shift Lever at 2,500
Position engine rpm
1st 1.4
2nd 1.9
3rd 3.3
4th 6.5
Rev. 1.9
*Maximum under SAE standard conditions of 500 ft. altitude and
85° F. temperature.
Direction Reverser. . . . Provides each speed listed above in for-
ward or reverse travel without shifting transmission gears. Hy-
draulically controlled. Oil clutches. Replaces engine clutch.
Engine: John Deere, variable speed, 3-cylinder, valve-in-head,
4-stroke cycle.
Dimensions
Heighttotopofhood 52in.
Over-allheightwithexhauststack 76in.
Over-all width (with 72-in. blade) 72 in.
Over-all length . . . .. .132 in.
Clearance at rear crossbar 13-1/4in.
Diesel
3-7/8 x 4-5/16 in.
152 cu. in.
16.3 to 1
1,500-2,500 rpm
110 lb. ft.
1300
Gasoline
Bore and stroke 3-7/8 x 3-7/8 in.
Piston displacement 135cu. in.
Compression ratio.. . .. 7.5 to 1
Operating speed range. 1,500-2,500 rpm
Maximum torque 110 lb. ft.
Rpm at maximum torque 1300
N.A.C.C. or A.M.A.
horsepower rated for
tax purpose. . . . . . .. 17.88
Lubrication... (Gas and Diesel engines)
Capacities (U.S. Measure):
Cooling system .. .. ..... ... .. .. .3-114 gal.
Fuel tank, gasoline and Diesel .. .. .. .. .. .. .. .. 22 gal.
Crankcase, including filter 9 qt.
Transmission 2-1/4 gal.
Final-drive cases(each) ... .. .. .. .. ... .. 3 qt.
Direction reverser case 3 gal.
17.88
Pressure system with
full-flow filter.
Crankshaft. .. (Gas and Diesel engines) Induction-hardened,
counterbalanced, statically and dynamically balanced.
Main and connecting
rod bearings. . . . . . .. Steel-backed, aluminum-lined, removable.
Main bearings:
Number 3 4
Diameter 3-1/8 in. 3-1/8 in.
Length(total) 3.560in. 4.715 in.
Cooling (gas and Diesel engines) Pressurized; with water
pump, thermostat, and fixed bypass. Suction or blower fan.
Governor Enclosed flyweight Flyweight integral
type with injection pump.
Carburetor Conventional
updraft.
Base Equipment:
Clutch-brake steering system.
Front bottom guard.
Heavy-duty track-roller guards.
12-volt starter and electrical
system.
Alternator.
Key ignition switch with safety
start.
Suction fan.
90 amp. dry-charge battery.
Air cleaner (dry-type).
Slip-fit exhaust stack.
Front hitch.
Fuel filters.
Oil-pressure
gauge.
Alternator-charge gauge.
Water-temperature gauge.
Electric hour meter.
Antifreeze.
Deluxe posture seat with arm-
rests. .
Tool tray.
Transistorized voltage regula-
tor.
Hydraulictrack-tension adjuster.
Outer sprocket shields.
Lights: front, rear, and panel.
Engine side shields.
Rear
bottom guard.
Air cleaner restriction indicator. . ...................
Fuel injection pump. ... ..................... Opposed plunger,
inlet metering, sin-
gle cylinder, distrib-
utor type.
Dry type.
12-volt with
alternator.
12-volt electric
starter.
Special Equipment:
Direction reverser.
Auxiliary remote hydraulic sys-
tem and breakaway couplings.
Remote hydraulic cylinder.
3-point hitch (Category 2).
Power takeoff assembly and
tachometer.
Swinging drawbar.
Calks for triple semi-grouser
shoes.
180 amp. hr. battery installation
-two 90 amp. batteries
(Diesel).
Notched snow sprockets.
High-altitude gasoline engine.
Track shoe types and sizes as
listed above.
Engine coolant heater
Sprocket shields (inner).
Spark arrester muffler.
Power steering.
Tachometer.
Winch
drive.
Cigarette lighter.
Pre-cleaner.
Belt pulley.
Ether starting
aid (Diesel).
Blower fan.
Grille screen.
Radiator sand screen for blower
fan.
Long muffler stack extension.
Canopy and seat belt.
Instrument panel cover.
Air cleaner.............
Electrical system... . . . .
Starting.................
Dry type.
12-volt with
alternator.
12-volt electric
starter.
Transmission... Selective sliding gear, 4 forward speeds and
1 reverse.
Engine Clutch... Foot operated. 11-inch single disk. (Replaced
by oil clutches when direction reverser is installed.)
Steering Clutch-brake system.
Clutches Multiple disk. 16 friction surfaces perclutch.
Brakes .
. . . . . " Contracting band. Bonded lining.
Over-All Gear Reduction Ratio:
In first gear 112t01
In high gear .. . . .. .. . . . . .. . .. .. .. .. . .. .. .. .. . . . . . . .24 to 1
Hydraulic System... Double with choice of crankshaft-driven
pump-15 gpm or 23 gpm.
Power Takeoff . Transmission driven, rear, 540 rpm.
(Special equipment.)
Track and Track Frame:
Track rollers, each side .. . . . .. .. . . . . . . . . .. .. .. . . . . .. . .. . . . .. . . .5
Track carrier roller, each side 1
~.
:)
13