Infinity CORONA DISCHARGE OZONE GENERATOR CD-7 THRU CD-15 - Manual (Page 3)

1
CD-7 thru CD-15 Infinity Corona Discharge Ozone Generator
SECTION 1
General Information
1A. Description
The Infinity™ Corona Discharge series ozone generator
described in this manual is designed to provide the ben-
efits of ozonated water in an environmentally safe and
effective manner. Infinity™generators are UL and NSF
listed. The high quality, specially engineered components
ensure efficient ozone output and reliable performance.
As a result of proper use of the Infinity™CD ozone gen-
erators, unpleasant effects of traditional chemical use,
(dry skin, red eyes, green hair) are virtually eliminated.
The Infinity CD ozone generator is safe and harmless to
your equipment if installed properly.
1B. Specifications
Ozone Output:
Ozone output (+10%):
CD-7 .......... 7 g/hr
CD-15 ........ 15 g/hr
Flow rate (max): CD-7 .......... 7 scfh (3.5 lpm)
CD-15 ........ 15 scfh (7 lpm)
% weight O
3
: 2.5-3.0%
Power Requirements:
Domestic:
CD-7 ..... 115VAC, 50/60 Hz, 1Ø, 6.0 Amp
CD-15 .... 115VAC, 50/60 Hz, 1Ø, 7.5 Amp
Export*: CD-7 ..... 230VAC, 50 Hz, 1Ø, 3.5 Amp
CD-15 .... 230VAC, 50 Hz, 1Ø, 4.0 Amp
Cooling Water Requirements:
.1 GPM (.4 lpm) of clean, filtered, fresh water.
NOTE: Typical pool water may be used for cooling.
Generator efficiency and life will be improved at inlet
temperatures of 80°F or less.
Inlet temperature: 50°F - 90°F (10°C - 32°C)
Inlet pressure: 15.0 - 40 psi (100 - 270 kPa)
Shipping Weight:
CD-7: Approx. 135 pounds / 61 kilos
CD-15: Approx. 150 pounds / 70 kilos
Location Requirements**:
Mounting: Floor or wall mount in a clean, protected
area using supplied brackets.
Ambient Temp: 40°F - 100°F (5°C - 40°C)
Ventilation:
6 air changes per hour. (min)
* 230V/50Hz unit supplied with enclosed step down trans-
former
**Protection from weather elements must be provided for
outdoor installations. Operating outside of the recom-
mended temp. ranges may result in damage not covered
under the manufacturer’s warranty.
1C. Warranty Summary
Limited Warranty:
2 years on entire generator
In addition to the two (2) year warranty:
3 years on weldments
5 years on high voltage electrodes
2 years on compressors that are maintained
according to operation and maintenance manual.
SECTION 2
Installation
2A. Location
CD-7 and CD-15 are designed for either floor or wall mount-
ing in a clean, protected area, either indoors or outdoors.
Locate generator out of reach of sprinklers or drainage
spouts. Allow sufficient access for maintenance and all
tubing and electrical wires. Ozone generator should be
installed no less than one foot above maximum water
level.
Figure 1: Wall Mount