Poulan Pro PR600Y22SHP LAWN MOWER User Manual

Page 11

BEFORE STARTING EN GINE

Read the engine manual packed with your
mower.
FILL ENGINE WITH OIL
Your lawn mower is shipped without oil in
the engine.
• Be sure mower is level and area around

oil fi ll is clean.

• Remove engine oil fi ller plug (oil fi ll cap/

dipstick on models so equipped).

• Slowly add oil. For type and grade of

oil to use, see “ENGINE” in the Mainte-
nance section of this manual.

• Fill to the top of slot in fi ller hole (to

“FULL” line on dipstick on models so
equipped). Do not overfi ll.

• Replace plug (oil fi ll cap/dipstick on

models so equipped) and tighten.

• Check oil level before each use. Add oil

as needed.

• To change oil, see Maintenance section

of this manual.

FILL GASOLINE TANK
• Fill gasoline tank with fresh, clean, un-

leaded gaso line. DO NOT USE PRE-
MIUM GASOLINE. BE CARE FUL NOT
TO OVERFILL TANK.

WARNING: Al co hol blended fuels (called
gaso hol or using ethanol or metha nol) can
at tract mois ture which leads to sepa ra tion
and for ma tion of acids during storage.
Acidic gas can damage the fuel system
of an en gine while in stor age. To avoid
engine prob lems, the fuel system should
be emptied before stor age of 30 days
or longer. Drain the fuel tank, start the
engine and let it run until fuel lines and
car bu re tor are empty. Use fresh fuel next
season. See Stor age In struc tions for
ad di tion al in for ma tion. Never use en gine or
car bu re tor clean er prod ucts in fuel tank or
per ma nent dam age may occur.

TO START ENGINE

CAUTION: The mow er blade rotates

whenever the engine is running.
• Move engine speed control to FAST

position (or to CHOKE/START position
on models equipped with choke feature).

• If your mower has a primer, to start a

cold engine, push primer as many times
as in struct ed in the engine manual
packed with your mower. Use a fi rm
push. This step is not usually nec es sary
when start ing an engine which has
already run for a few minutes.

• Hold operator presence control bar

down against han dle.

MODELS WITH RECOIL START ER
• Pull starter handle quickly. Do not allow

starter rope to snap back.

MODELS WITH ELECTRIC START ER
• Push the engine start button (or turn the

key on models so equipped).

IMPORTANT: Do not crank engine more
than fi ve continous seconds each time you
try to start. Wait 5 to 10 seconds between
each attempt.
ALL MODELS
• For engines equipped with choke, slowly

move engine speed control lever to
FAST after engine starts.

TO STOP ENGINE

• To STOP engine, release operator pres-

ence control bar.

NOTE: For engines with a primer, it may
be nec es sary to repeat priming steps
in cooler weather. In warmer weath er,
overpriming may cause fl ood ing and
en gine will not start. If you do fl ood
engine, wait a few minutes before
attempting to start and DO NOT repeat
priming steps.

Recoil
starter
handle

Operator
presence
control bar

CAUTION: Do not run your lawn mower

without rear mulcher plate or plug in place
or approved grass catcher in place. Never
at tempt to op er ate the lawn mow er with
the rear door re moved or propped open.

GRASS CATCHER
(REAR BAGGING MODELS ONLY)

TO EMPTY GRASS CATCHER
• Simply open rear door and lift grass

catcher up and away from mower.

NOTE: Do not drag the bag when
emptying. It will cause unnecessary wear.

CAUTION: Under nor mal usage, the

catch er material is subject to de te ri o ra tion
and wear and should, therefore, be
checked frequently for replacement. Any
replacement catcher should be checked
to ensure compliance with original
man u fac tur er's spec i fi

ca tions.

CAUTION: Do not run lawn mower

with out the rear door, ap proved grass
catcher or clip ping de fl ec tor in place.
Never at tempt to op er ate mower with the
rear door removed or propped open.

OPERATOR PRESENCE CONTROL
BAR

Your lawn mower is equipped with an op-
er a tor presence control bar which re quires
the operator to be po si tioned behind the
lawn mower handle in order to start and
operate the lawn mower.

CAUTION: Federal reg u la tions require

an en gine control to be in stalled on this
lawn mower in order to min i mize the
risk of blade contact injury. Do not un der
any cir cum stanc es attempt to de feat the
func tion of the operator con trol. The blade
turns when the engine is running.

Open mulcher door

Discharge defl ector

SIMPLE STEPS TO REMEMBER WHEN
CONVERTING YOUR “COMBI-CUT”
LAWN MOWER

FOR MULCHING -
• Rear mulcher plate installed and rear

door closed.

• Mulcher door closed.

FOR REAR BAGGING -
• Rear mulcher plate removed.
• Grass catcher installed.
• Mulcher door closed.

FOR SIDE DISCHARGING -
• Rear mulcher plate installed and rear

door closed.

• Discharge defl ector installed.