Woods Equipment 7000 - Manual (Page 6)

4 Safety
UM60/72 Mower Safety Rules (Rev. 7/22/2004)
„ If the clutch or brake pedal mechanisms can
contact mower components, do not put mower into
service until properly adjusted.
„ Do not put mower into service unless discharge
chute is installed and in good condition. Replace if
damaged.
„ Keep bystanders away from equipment.
„ Never go underneath equipment (lowered to the
ground or raised) unless it is properly blocked and
secured. Never place any part of the body under-
neath equipment or between moveable parts even
when the engine has been turned off. Hydraulic
system leak down, hydraulic system failures,
mechanical failures, or movement of control levers
can cause equipment to drop or rotate unexpect-
edly and cause severe injury or death. Follow Oper-
ator's Manual instructions for working underneath
and blocking requirements or have work done by a
qualified dealer.
„ Never direct discharge toward people, animals,
or property.
„ Do not operate equipment while under the influ-
ence of alcohol or drugs.
„ Operate only in daylight or good artificial light.
„ Keep hands, feet, hair, and clothing away from
equipment while engine is running. Stay clear of all
moving parts.
„ Always comply with all state and local lighting
and marking requirements.
„ Never allow riders on power unit or attachment.
„ Power unit must be equipped with ROPS or
ROPS cab and seat belt. Keep seat belt securely
fastened. Falling off power unit can result in death
from being run over or crushed. Keep foldable
ROPS systems in “locked up” position at all times.
„ Always sit in power unit seat when operating
controls or starting engine. Securely fasten seat
belt, place transmission in neutral, engage brake,
and ensure all other controls are disengaged
before starting power unit engine.
„ Operate tractor PTO at the RPM speed stated in
“Specifications” section.
„ Do not operate PTO during transport.
„ Do not operate auxiliary hydraulics during
transport.
„ Look down and to the rear and make sure area
is clear before operating in reverse.
„ Do not operate on steep slopes.
„ Do not stop, start, or change directions sud-
denly on slopes.
„ Use extreme care and reduce ground speed on
slopes and rough terrain.
„ Watch for hidden hazards on the terrain during
operation.
„ Stop power unit and equipment immediately
upon striking an obstruction. Turn off engine,
remove key, inspect, and repair any damage before
resuming operation.
„ Before dismounting power unit or performing
any service or maintenance, follow these steps:
disengage power to equipment, lower the 3-point
hitch and all raised components to the ground,
operate valve levers to release any hydraulic pres-
sure, set parking brake, stop engine, remove key,
and unfasten seat belt.
„ Before working underneath, read Operator's
Manual and Blocking Method section Disconnect
driveline, raise mower, install transport lock,
securely block up all corners, and check stability.
Secure blocking prevents equipment from drop-
ping due to hydraulic leak down, hydraulic system
failures, or mechanical component failures.
TRANSPORTATION
„ Always comply with all state and local lighting
and marking requirements.
„ Never allow riders on power unit or attachment.
„ Do not operate PTO during transport.
„ Watch for hidden hazards on the terrain.
„ A minimum 20% of tractor and equipment
weight must be on the tractor front wheels when
attachments are in transport position. Without this
weight, tractor could tip over, causing personal
injury or death. The weight may be attained with a
loader, front wheel weights, ballast in tires or front
tractor weights. Weigh the tractor and equipment.
Do not estimate.
„ Power unit must be equipped with ROPS or
ROPS cab and seat belt. Keep seat belt securely
fastened. Falling off power unit can result in death
from being run over or crushed. Keep foldable
ROPS system in “locked up” position at all times.
„ Do not operate or transport on steep slopes.
„ Do not operate or transport equipment while
under the influence of alcohol or drugs.
SAFETY RULES
ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED!